1997 Chevrolet Cavalier complaints

CONSUMERS FUEL LINE LEAKED AND WAS REPAIRED. A FEW DAYS LATE IT DEVELOPED ANOTHER PIN HOLE LEAK. *TS THE CONSUMER SMELLED FUEL WHILE DRIVING. HE LATER DISCOVERED THAT THE RETURN FUEL LINE RUNNING DOWN THE SIDE OF THE DRIVER'S SIDE OF THE CAR WAS LEAKING ONTO THE MUFFLER. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE IT WAS TEMPORARILY FIXED. ABOUT A MONTH LATER THE FULE LINE RNNING UP THE PASSENGER SIDE OF THE VEHICLE DEVELOPED A PIN HOLE LEAK. *NM

1997 CHEVROLET CAVALIER BRAKE LINES WERE RUSTED.*MR THE REAR BRAKE LINES AND HOSES HAVE BEEN REPLCED THREE TIMES DUE TO RUST. THE CONSUMER REQUESTED REOMBURSEMENT FROM THE MANUFACTURER. *NM

DT: THE DASH AREA OF THE VEHICLE CAUGHT ON FIRE, IT STARTED AROUND THE IGNITION SWITCH. THEY DO HAVE A RECALL NOT SURE IF IT INCLUDES THIS VEHICLE. THE VEHICLE STARTED WITHOUT THE KEYS IN THE IGNITION AFTER TURNING IT OFF, AND THAT WAS WHEN IT CAUGHT ON FIRE. THIS HAPPENED ON JULY 6, 2005. THE FIRE DEPARTMENT AND INSURANCE COMPANY CAME OUT AND INSPECTED VEHICLE. *AK

RACK AND PINION STEERING FAILURE. CAR FAILS TO STEER LEFT AND ALMOST CAUSES A CRASH DUE TO LACK OF BEING ABLE TO STEER. ABILITY TO STEER TO THE RIGHT IS FINE. MAKING LEFT HAND TURNS NOW WORRIES ME WHEN DRIVING. DURING MY COMMUTE I AM CONSTANTLY WORRIED WHETHER OR NOT I CAN MAKE A LEFT-HAND TURN. THIS HAS ALMOST CAUSED THREE ACCIDENTS. WHY WASN'T THIS RECALLED CONSIDERING ALL THE THE PROBLEMS WITH THIS LISTED WITH THE NHTSA? PLENTY OF GM MODELS HAVE HAD THIS PROBLEM. WHY SHOULD CONSUMERS TAKE THE FALL WHEN IT STEMS BACK TO THE MANUFACTURER?

DT: CONTACT STATES THE TIMING CHAIN ON HER VEHICLE BROKE ON A BUSY ROAD. THE TIMING CHAIN HAS BEEN REPLACED, BUT WITHIN 6 MONTHS THE TIMING CHAIN BROKE AGAIN. THE ENGINE WAS REPLACED IN THE VEHICLE. THE CAR STARTED MAKING A LOUD KNOCKING NOISE, NOW THE VEHICLE WILL ONLY GO APPROXIMATELY 15 MPH.*AK

I HAVE A 97 CHEVROLET CAVALIER CONVERTIBLE THAT I HAVE HAD TO TAKE IN 3 TIMES BECAUSE THE DRIVER SIDE POWER WINDOW STOPPED WORKING AND 3 TIMES BECAUSE THE PASSENGER SIDE WINDOW QUITE WORKING.

CONSUMER INQUIRING AS TO WHETHER OR NOT THE RECALLS ON HIS VEHICLE CAN BEEN FIXED BY THE MANUFACTURER, IF SO CAN THEY BE REPAIRED FREE OF CHARGE. *MR *NM

TAKING A LEFT TURN IN A 1997 CHEVROLET CAVALIER, THE STEERING WHEEL LOCKED, CAUSING THE CAR TO VEER LEFT WITHOUT ABILITY TO CORRECT UNTIL EXPLICIT FORCE WAS APPLIED. THE INCIDENTS LEFT THE STEERING WHEEL WITH SLUGGISH CONTROL AND THEREFORE UNSAFE FOR DRIVING. THE CAR WAS TAKEN TO THE DEALERSHIP WHICH ASKED FOR 800$ FOR THE REPAIR OF THE STEERING WHEEL. INFORMATION ABOUT THIS DEFECT IN GM CARS HAS BEEN SEEN THROUGHOUT THE INTERNET, AND A COMPLAINT IS MORE THAN NECESSARY.

WHILE VEHICLE WAS PARKED AND RUNNING IDLE DRIVER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. OWNER CONTACTED THE MANUFACTURER, WHO SUGGESTED THAT THE VEHICLE BE PUT ON A DIAGNOSTIC MACHINE TO DETERMINE FAULT.*AK

CONSUMER RECEIVED NHTSA RECALL CAMPAIGN 02V286000 CONCERNING RACK AND PINION STEERING. HE TOOK VEHICLE TO DEALER FOR SERVICE. SEVERAL DAYS LATER, AFTER REPLACING THE DEFECTIVE COMPONENT, HE EXPERIENCED THE SAME PROBLEM. POWER STEERING FAILED WHEN MAKING A RIGHT TURN AT VARIOUS SPEEDS.*AK

THE CYLINDER LOCK HAS BEEN REPLACED FOUR TIMES. THE VEHICLE IS IN THE ON POSITION. THE KEY IS STUCK. CONSUMER HAD TO LET THE VEHICLE RUN UNTIL IT SHUT ITSELF OFF, MEANING IT HAD TO RUN OUT OF GAS. IT WILL NOT LET THE CONSUMER RELEASE THE KEY FROM THE IGNITION.*AK

WATER PUMP LEAKING AND NEEDS TO BE REPLACED FOR THE THIRD TIME. ONE WATER PUMP WAS REPLACED UNDER WARRANTY. A SECOND WATER PUMP FAILED JUST AFTER THE 36,000 WARRANTY WAS UP AND COST ME EXTRA TO REPLACE BECAUSE OF THE POOR DESIGN OF THE ENGINE WHICH REQUIRES THAT IT BE REMOVED TO REPLACE THE WATER PUMP. THE THIRD HAS JUST FAILED FOR UNKNOWN REASONS. THE VEHICLE ONLY HAS 75,000 MILES ON IT.

THE CONSUMER WAS DRIVING APPROXIMATELY 50 MPH, WHEN SHE TRIED TO AVOID AN ACCIDENT, BUT VEERED RIGHT OFF THE ROAD ONTO A SAFETY SCHOOL COMPLEX. SHE THEN HIT A MAILBOX POLE. THE AIRBAGS FAILED TO DEPLOY ON IMPACT. *JB THE CONSUMER STATED THAT SHE HIT A CURB AND THE VEHICLE SAILED OVER IT INTO THE MAILBOX. *TC

THE TEMPERATURE GAUGE IN CAR RISES TO VERY HOT. THERE IS NO STEAM OR ANYTHING COMING FROM CAR, BUT YOU MUST STILL STOP ON THE HIGHWAY AND WAIT FOR THE GAUGE TO READ COOL BEFORE YOU CAN CONTINUE ON. THIS ALSO HAPPENS IF YOU ARE ON A LINE FOR ANY AMOUNT OF TIME. BECAUSE OF THIS PROBLEM I OWN A CAR THAT I DRIVE ONLY AROUND THE NEIGHBORHOOD. *JB

INCIDENT TO REPORT: 97 CHEVROLET CAVALIER BACK WINDOW CRACKED WHEN CLOSED DOOR. THIS RESULTED IN BROKEN GLASS ALL OVER MY INFANT'S CAR SIT AND TOYS. IF MY INFANT WAS IN THE CAR AT THE TIME, SHE WOULD HAVE SUFFERED MAJOR INJURY. *NM

HEAD GASKET REPLACED @27000 MILES, FUEL PUMP @ 30000 AND AGAIN AT 96000 MILES. BRAKES REPLACED 2X A YEAR FOR 5 YEARS. DRIVER'S SIDE DOOR DOESN'T SEAL PROPERLY. FAN ONLY WORKS ON SPEED 3 OR 4. *NM

MY 1997 CHEVROLET CAVALIER WAS PURCHASED IN JUNE OF 1999. SINCE THAT TIME, I HAVE HAD AT LEAST TWELVE INCIDENTS WITH THE FAILURE OF MY TAIL LIGHTS. THERE SEEMS TO BE SOME TYPE OF SHORTAGE IN THE LINE BECAUSE I HAVE PURCHASED MORE BULBS THAN I WOULD LIKE TO REMEMBER. I HAVE ALSO RECEIVED ONE CITATION AS WELL AS TWO WARNINGS IN REFERENCE TO THE BROKEN TAIL LIGHT. RECENTLY I SAW THAT THE MORE NEWER MODELS OF THE CAVALIER HAVE BEEN RECALLED TO FIX THE TAIL LIGHT BUT NOT THE LATER ONES. HOPEFULLY THIS COMPLAINT WILL HELP TO RECTIFY THE PROBLEMS THAT I HAVE BEEN HAVING.*AK

DEFECTIVE STEERING COLUMN IN 97 CAVALIER, CAUSED AN ACCIDENT RESULTING IN EXTREME INJURIES. *BF NHTSA CAMPAIGN ID NUMBER : 02V286000. THE CONSUMER WAS MAKING A SLOW LEFT AND THE VEHICLE PULLED TO THE RIGHT. THE AIR BAG DEPLOYED LATE STRIKING THE CONSUMERS LEFT EYE. *TC *JB

WHEN TRYING TO AVOID A CRASH AT 15 MPH VEHICLE WENT INTO A DITCH. THE FRONTAL AIR BAGS DEPLOYED AFTER THE VEHICLE CAME TO A COMPLETE STOP. CONSUMER SUFFERED INJURIES. HAD THE VEHICLE TOWED TO DEALERSHIP, WHO COULD NOT RESOLVE THE PROBLEM. *AK

CONSUMER WAS TRAVELING 35 MPH AND BOTH FRONTAL AIR BAGS WENT OFF INADVERTENTLY. NO INJURIES REPORTED. CONSUMER WAS ABLE TO DRIVE IT HOME, AND WILL CONTACT THE DEALER. *AK

CAR SMELLS LIKE GAS IN WARM AND HOT WEATHER, SMELL COMES IN THROUGH THE VENT SYSTEM. CHEVY MED-VED IN ARVADA COLORADO CANNOT FIND THE PROBLEM, BUT REPLACED THE EXHAUST GAS CANISTER, STATING IT WAS SATURATED WITH GAS, CAR STILL HAS THE SAME SMELL AFTER THIS REPLACEMENT. MANY OTHER REPAIR SHOPS REFERRED ME TO THE DEALERSHIP WHICH I TOOK THE CAR TO. THE PROBLEM STILL EXISTS, A POTENTIAL FIRE HAZARD IF FUMES OF GAS ARE EXISTENT-THIS IS MY CONCERN, NOT TO MENTION THE SMELL THAT COMES IN THE CAR IS NOT OF CLEAN AIR-MY SECOND CONCERN. SUMMARY OF ACTIVITY: THIS PROBLEM HAS BEEN NOTICED SINCE SUMMER 2000. AIR CONDITIONING AND REPAIR SHOP REFERS ME TO DEALERSHIP, ADVISES ME TO STOP DRIVING THE CAR BECAUSE IT IS A FIRE HAZARD. IN 2000 AND 2001, FAILURE TO DUPLICATE GAS LEAK SMELL WHEN TAKEN TO DEALERSHIP. IN SUMMER 2004, GAS LEAK EVIDENT AT DEALERSHIP, REPLACED E-VAC CANISTER, GIVES ADVICE NOT TO "TOP OFF THE TANK WHEN FILLING UP WITH GAS." OCTOBER 2004, SMELL IS STILL EVIDENT. *NM

WHILE DRIVING, THE STEERING WHEEL FAILED. THE CONSUMER LOST CONTROL OF THE VEHICLE AND STRUCK A STEEL POLE. BOTH FRONTAL AIR BAGS DID DEPLOY. THE PASSENGER WAS INJURED AND WENT TO THE HOSPITAL THE NEXT DAY. THE INSURANCE COMPANY HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE RACK PINION NEEDED REPLACEMENT. THE INSURANCE COMPANY TOTALED THE VEHICLE. PLEASE FILL IN ADDITIONAL INFORMATION.

MY ABS LIGHT WENT ON AFTER I HAD THE BRAKES DONE. THIS OCCURED SEVERAL WEEKS AFTER. MY MECHANIC LOOK AT IT AND SAID THE COMPUTER BOARD WAS BROKEN AND IT WOULD BE EXPENSIVE. SO NOW THE AUTOMATIC BRAKING SYSTEM DOES NOT WORK.*AK

CONSUMER HAD THE SAME PROBLEM AS STATED IN NHTSA RECALL 02V07000. ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS. THIS RECALL FAILED. *AK

WHILE MAKING A RIGHT TURN RACK PINION STEERING MALFUNCTIONED. CONSUMER HAD THE VEHICLE TOWED TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT RACK AND PINION: PINION SHAFT NEEDED TO BE REPLACED. *AK

WHILE DRIVING VEHICLE STALLED. CONSUMER RESTARTED VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. VEHICLE WAS PLACED ON THE DIAGNOSTIC MACHINE. MECHANIC DETERMINED THAT THE MACHINE CODES SHOWED THAT THE FUEL INJECTIONS NEEDED TO BE REPLACED. BUT THE NEXT DAY VEHICLE STALLED AGAIN, AND CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. HOWEVER, MECHANIC WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK

NHTSA RECALL CAMPAIGN 02V186000; STEERING ASSEMBLY; THE OWNER TOOK HER VEHICLE IN FOR THE RECALL BUT WAS INFORMED THAT OTHER ITEMS WERE WRONG. THOSE ITEMS WERE REPAIRED SEVERAL DAYS BEFORE. IT APPEARS THAT THEIR INTEREST WAS NOT ABOUT THE STEERING, IN WHICH THEY ONLY REPLACED THE LOWER PINION. THE CONSUMER QUESTIONED THE REPAIRS MADE TO HER VEHICLE ALONG WITH THE BRAKE LIGHTS FAILING ONCE THE VEHICLE WAS RETURNED TO HER. THEY ARE NOT CLAIMING ANY FURTHER RESPONSIBILITY. PLEASE PROVIDE DETAILS. *JB TIRE WAS HIT WITH A NAIL CREATING AN UNBALANCED TIRE. *TC

CONSUMER WAS DRIVING THROUGH A PARKING LOT AND WHEN TURNING INTO THE DRIVEWAY RACK AND PINION STEERING FAILED. CONSUMER TURNED THE STEERING WHEEL, BUT THE WHEELS OUTSIDE THE VEHICLE DID NOT TURN, RESULTING IN A COLLISION, AND INJURING THE DRIVER. *AK

VEHICLE WAS INVOLVED IN A COLLISION. WHILE DRIVING VEHICLE STALLED, RESULTING IN A REAR END COLLISION. UPON IMPACT, AIR BAG FAILED TO DEPLOY ON DRIVER'S SIDE. DRIVER SUSTAINED INJURIES. *AK

THE HEAD GASKET LEAKED WATER. AS A RESULT, CONSUMER HAD TO CHECK THE WATER LEVEL DAILY TO MAKE SURE THAT ENGINE WOULD NOT OVERHEAT. *AK

THE PASSENGER'S SIDE REAR TIRE LOST AIR . AS A RESULT, CONSUMER HAD TO FILL THE TIRE WITH AIR EVERY TWO DAYS. *AK

DEFECT SUMMARY: THE ACCELERATOR CONTROL CABLE COULD HAVE BEEN KINKED DURING ASSEMBLY CAUSING HIGH ACCELERATOR PEDAL EFFORT, STICKING ACCELERATOR CONTROL CABLE, OR A BROKEN ACCELERATOR CONTROL CABLE. *AK CONSEQUENCE SUMMARY: IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS, UNWANTED ACCELERATION AND/OR LOSS OF THROTTLE CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE ACCIDENT. REQUESTED CORRECTIVE SUMMARY: DEALERS WILL REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.

MY DRIVER WINDOW CAME OFF THE TRACK AND FELL DOWN TO THE BOTTOM OF THE DOOR-THE GLASS DIDNT BRAKE BUT IT FELL FOR NO REASON-IT COULD HAVE SHATTERED-IS THIS A COMMON OCCURANCE??ITS A 1997 CHEVY CAVALIER-2 DOOR. *AK

WHILE DRIVING, THE HORN FAILED TO WORK INTERMITTENTLY. *AK THERE WAS ERRATIC HORN OPERATION. THE HORN DIDN'T WORK 50% OF THE TIME. THE DEALERS NEVER RESOLVED THE PROBLEM. *SC *JB

CONSUMER ATTEMPTED TO START VEHICLE BUT IT FAILED TO DO SO. CONSUMER LIFTED UP THE HOOD AND NOTICED THAT MAIN WIRE TO STARTER CAUGHT ON FIRE. THE DRIVER WAS ABLE EXTINGUISH THE FIRE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED THE IGNITION SWITCH DUE TO A WORN OUT RELAY SWITCH. *AK

THE TRANMISSION IN THESE CARS ARE VERY FAULTY, AND THE COMPANY SHOULD RE-CALL THEM. I THINK THAT THERE IS A NEED FOR THEM TO EXPLAIN THEMSELVES TO THE CONSUMER FOR WE OUR THE PEOPLE BUYING THESE BAD CARS. I JUST BOUGHT MINE AND IT HAS A TRANS. PROBLEM ALREADY AND THE CAR ONLY HAS 83,000 MILES ON IT. I WANT ANSWERS ON THIS AND THE COMPANY TO FIX THESE PROBLEMS ON THESE CARS. THERE WERE OVER (66_) NOTED PROBLEMS ON THIS CAR ALONE AND I THINK THAT YOU GUYS MADE THEM BAD THEN YOU GUYS MAKE THEM RIGHT AND SEND OUT RECALL NOTICES TO THE CONSUMER. BEFORE SOME-ONE COULD GET HURT IN A REALLY BAD CAR ACCIDENT OR EVEN DIE IN ONE BECAUSE YOU COULD NOT PUT RECALLS OUT TO THE PEOPLE WHO OWN THESE CARS. *AK

HEAD GASKET BROKE. LOOKING AT $2,600 TO FIX, EVEN THOUGH LOW MILES. *AK

WHILE THE CONSUMER WAS DRIVING, THE HOOD OPENED UP AND STRUCK THE FRONT WINDSHIELD. *PH *NM

RACK AND PINION STEERING WENT OUT- WAS LATER A RECALL. HEAD GASKET CRACKED LEAKING OIL AND ANTIFREEZE. AIRBAG RECALL.

THE FUEL PUMP OVERHEATS WHEN IDLING AND IT WENT OUT. (NOISILY, IT SOUNDED LIKE A DENTIST'S DRILL) BEFORE GOING OUT I TOOK IT IN FOR A DIAGNOSTIC BECAUSE THE CAR WAS PUMPING GAS FUMES INTO THE CAB AND THEY FOUND NOTHING WRONG. BECAUSE IT IS IN THE GAS TANK IT COST ME OVER $700 TO REPLACE.

SEAT BELTS, BY BUCKELS HAVE A PLASTIC PIECE THAT HAS CRACKED FROM HEAT AND PROVENTS IT TO STAY TIGHT ON ALL 4 BELTS. THIS ALSO PROVENTS ME, PASENGER, AND MY CHILDRENS CAR SEATS FROM BEING TIGHT AND SECURLEY FASTEND. PORE DESIGN ON THESE.

IN FEBRUARY, I HAD TAKEN MY 1997 CHEVY CAVALIER TO THE DEALER FOR THE BEARING RECALL IN FEB OF 2003, AFTER THAT I HAD PROBLEMS WHEN TURNING LEFT MY STEERING GETS HARD AND HAVE NO CONTROL, I HAD THE RACK CHANGED, IN JULY OF 2003 IT WORKED FINE UP TILL SAT. JAN 10, 2004 I HAD NO CONTROL WHEN TURNING LEFT AND RIGHT IT WAS LIKE I HAD NO POWER STEERING. AND IT STILL DOES IT, AND IM AFRAID THAT IT COULD INJURE MYSELF AND MY CHILDREN. I SAW THE RECALL THAT GM WAS DOING AND THOUGHT THAT THIS COULD BE MY PROBLEM AS WELL. *LA

WHILE THE VEHICLE WAS PARKED THE VEHICLE'S DRIVER SIDE AIRBAG DEPLOYED INADVERTENTLY. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM

CAR SMELLS LIKE GAS ALL THE TIME. WAS TOLD HAVE TWO LEAKS IN FUEL INJECTOR. *JB

CONSUMER RECEIVED A BILL FOR CHARGES FOR REPAIRS THAT WAS NOT AUTHORIZED FOR VEHICLE.*MR (NAR) *CB

COMPLAINT REGARDING 1997 CHEVROLET CAVALIER SERIOUS SAFETY DEFECTS. *MR THERE WERE TWO CRASHES. ONE WHEN THE VEHICLE WAS PARKED AND THE OTHER WHEN THE VEHICLE WAS REAR ENDED. THE DIAGNOSIS INCLUDED PREVIOUS BOTCHED WORKMANSHIP. ALIGNMENT AND SUSPENSION COULDN'T BE PERFORMED. THE VEHICLE WAS UNSAFE DUE TO BOTCHED MECHANIC WORK WHICH WAS UNREPORTED TO THE CONSUMER OR WITHIN THE BILL OF SALE. *SCC *JB

THE VEHICLE WAS REPAIRED FROM A PREVIOUS RECALL. RECALL NO. # 02V286000, SUBJECT: POWER STEERING ASSEMBLY. WHILE TURNING INTO A PARKING LOT THE STEERING WHEEL BECAME VERY HARD TO TURN. THIS IN TURN CAUSED THE CONSUMER'S GRANDDAUGHTER FRONT PASSENGER SIDE TO COLLIDE WITH THE FRONT DRIVERS SIDE OF ANOTHER VEHICLE. A POLICE DID ARRIVE ON THE SCENE AND CITED THE CONSUMER'S GRAND DAUGHTER. THE CONSUMER'S GRANDDAUGHTER AND THE OTHER DRIVER BOTH SUFFERED WHIPLASH. *PH

VEHICLE'S AIR BAG INADVERTENTLY DEPLOYED WHILE DRIVING.*MR *TS *JB

VEHICLE WAS TAKEN TO DEALER FOR RECALL REPAIRS ON THE WIRING HARNESS. CONSUMER NOTICED THAT WHILE DRIVING VEHICLE WAS RUNNING VERY ROUGH. *AK

WHEN ATTEMPTING TO START VEHICLE IGNITION SWITCH STUCK. RECALL 02V070000 REPAIRS WERE PERFORMED, BUT PROBLEM STILL RECURRED. ALSO, WHILE DRIVING THE BEARING HUB PRODUCED A GRINDING NOISE ON THE LEFT SIDE. THE CAUSE HAS YET TO BE DETERMINED BY THE MECHANIC. *AK