2008 Can-Am Spyder GS

Defect. Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2009 Can-Am Spyder GS and model year 2010 Can-AM Spyder RS vehicles. Fuel vapors may exit the fuel vapor canister vent hose in the enclosed engine compartment.

Risk. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

Remedy. BRP will notify owners, and dealers will inspect the fuel vapor canister vent hose and replace and re-route it, as necessary, free of charge. The safety recall began on December 26, 2012. Owners may contact BRP AT 1-888-638-5397.

Defect. Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2012 Can-Am Spyder GS, RS, and RT series vehicles. The fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.

Risk. If the fuel cap does not seal properly, it may leak fuel vapors. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

Remedy. BRP will notify owners and send them a replacement fuel cap, free of charge. The safety recall is expected to begin in mid-January 2013. Owners may contact BRP AT 1-888-638-5397.

Defect. ON CERTAIN PASSENGER VEHICLES, THERE IS A PRESENCE OF AN ABNORMAL QUANTITY OF AIR IN THE HYDRAULIC CIRCUIT OF THE FRONT BRAKE. ALSO SOME VEHICLES MAY HAVE ONE OR TWO BRAKE FLUID RESERVOIR CAPS THAT ARE SEALED AND THIS COULD CREATE A VACUUM WHICH COULD LEAD TO ADSORPTION OF AIR INTO THE BRAKE CIRCUITS. THE BRAKE PEDAL MAY GO ALMOST TO THE FLOOR WHEN DEPRESSING.

Risk. A DRIVER MAY BE UNABLE TO STOP THE VEHICLE AS EXPECTED INCREASING THE RISK OF A CRASH.

Remedy. BRP HAS NOTIFIED EACH OWNER INFORMING THEM OF THIS PROBLEM AND SCHEDULING A PICK-UP TIME TO RETRIEVE THE VEHICLE. DEALERS WILL INSPECT AND PERFORM A BLEEDING OF THE BRAKE SYSTEM IS NEEDED. THE BRAKE FLUID RESERVOIR CAPS WILL BE REPLACED AND THE BRAKE SYSTEM PRESSURE WILL BE VALIDATED. THE RECALL BEGAN ON NOVEMBER 21, 2007. OWNERS MAY CONTACT BRP AT 1-888-864-2002.

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER GS. WHILE DRIVING 55 MPH, THE STEERING SEIZED. THE CONTACT PULLED THE VEHICLE OVER TO GAIN CONTROL OF THE VEHICLE. THE DPS AND CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED THAT THE DPS FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 14,000. *TR *AS *BF *AS 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

2008 CAN-AM SPYDER GS THIS BIKE IS WORTHLESS AND SHOULD BE RECALLED BACK. MY BIKE WILL NOT GO OUT OF LIMP MODE EVER AGAIN. CAN'T BE FIXED. SPENT A LOT OF MONEY AND TIME TRYING TO FIGURE OUT ISSUE AT DEALER. NO TECHNICIAN THAT EVEN KNOW THE YEAR AND ANY PROBLEM ISSUES. RECALL THIS BIKE OR AT LEAST MAKE IT RIGHT!

I PURCHASED A 2008 CAN-AM SPYDER GS IN 2008. VIN [XXX] VEHICLE PURCHASE DATE 03/06/2008 BRP ISSUED A RECALL ON SEPT 7, 2010 FOR A DYNAMIC POWER STEERING (DPS) UNIT REPLACEMENT HTTPS://CAN-AM.BRP.COM/SPYDER/OWNERS/SAFETY/SAFETY-RECALLS/DYNAMIC-POWER-STEERING--DPS--UNIT-REPLACEMENT.HTML THE RECALL WAS DUE TO A FAULTY POWER STEERING CONTROL UNIT, WHICH SEVERELY HAMPERED THE ABILITY TO TURN THE BIKE, ESPECIALLY AT HIGHER SPEEDS FOR SHARPER TURNS. I HAD THE DPS REPLACED IN 2011. THE UNIT HAS AGAIN FAILED, AND THE REPAIR SHOP (DEL AMO MOTORSPORTS IN REDONDO BEACH, CA...WHO DID THE ORIGINAL REPLACEMENT) HAS CONFIRMED THAT THE FAILURE IS THE EXACT SAME FAILURE AS THE RECALL. I FILED A CASE NUMBER WITH BRP, BRP CASE # 01010694, WHO STATED THAT THEY WOULD NOT AUTOMATICALLY COVER THE REPLACEMENT AGAIN, AS THIS HAD ALREADY BEEN REPAIRED. UPON FILING THE REQUEST, CAN-AM DID REJECT THE CLAIM AND SAID THEY WILL NOT COVER THE REPAIRS AS A RECALL. THIS IS NOT SIMPLY A REPAIR TO A REPAIR. THIS IS ANOTHER FAILURE OF THE RECALL, WHICH MEANS THIS SHOULD FALL UNDER THE RECALL CONDITIONS AGAIN. I AM NOT ASKING FOR CAN-AM TO COVER ALL OF THE WORK, SIMPLY COVER THE PART (THE DPS UNIT), WHICH COSTS OVER $1200 USD. AS A RECALLED PART THEY SHOULD HONOR THE PART FOR AN ACCEPTABLE PERIOD OF PERFORMANCE. IN THIS CASE, THE REPLACED DPS UNIT HAS ONLY LASTED FOR 2-3000 MILES, WHICH IS UNACCEPTABLE. BRP SHOULD COVER ALL OF THE RECALL REPAIR, OR AT LEAST THE PART (THE NEW DPS UNIT), WHICH TOTALS OVER $1200 USD.

MY VSS,ABS, AND 4 OTHER CODES CONSTANTLY FLASH. THIS MACHINE LOSES POWER BEFORE I GET TO THIRD GEAR. I WAS TRAVELING ON A BUSY CITY STREET DURING LUNCH HOUR TRAFFIC WHEN OUT OF NO WHERE I LOSE POWER AND I GET A CHECK DPS ,VSS FAULT, HIGHTEMP, CHECK ENGINE AND ABS WARNINGS. ALMOST REAR ENDED BEFORE SWAYING OFF THE ONTO THE SHOULDER. ONE DAY ITS RUNNING FINE THE NEXT DAY EVERY WARNING LIGHT ON IT COMES ON THERE ARE SOME REAL ISSUES FOR A BIKE THAT HAS BEEN WELL MAINTAINED AND WITH SUCH LOW MILES . THIS PURCHASE HAS CHANGED MY MIND ABOUT PURCHASING A NEW ONE . I LOVE THE WHOLE CONCEPT BUT THE MANUFACTURER NEEDS TO GET A LOT OF THINGS CORRECTED TO WIN ME OVER AGAIN. I WILL NOT ALLOW MY SON OR WIFE TO RIDE BECAUSE I FEAR FOR THEM IF THIS THING MALFUNCTION IN TRAFFIC. PLEASE BPR DO SOMETHING TO FIX THIS MADNESS. GREAT IDEA BUT IT HAS NOT LIVED UP TO EXPECTATIONS, TOO MUCH MONEY SPENT FIXING THIS BIKE. I HAVE SPENT OVER $2000 IN REPAIRS AND I STAY IN LIMP MODE. NOT FAIR ! BACK TO THE SHOP AGAIN ,THIS TIME IT WILL HAVE A FOR SALE SIGN ATTACHED !!!!

WHILE DRIVING MY 2008 CAN AM SPYDER ON CT-2 WEST BOUND IN CONNECTICUT AT APPROXIMATELY 6:30PM IN SLOW MOVING, STOP & GO TRAFFIC MY WIFE (WHO WAS THE PASSENGER) NOTICED BY HER RIGHT FOOD THERE WERE FIRE FLAMES COMING FROM THE VEHICLE. SIMULTANEOUSLY I NOTICED WHITE SMOKE COMING FROM THE FRONT OF THE VEHICLE. I STOPPED THE BIKE IMMEDIATELY AND BOTH ME AND MY PASSENGER DISMOUNTED THE BIKE. WE QUICKLY MOVED AWAY FROM THE BIKE AS WE FEARED OUR SAFETY WAS IN JEOPARDY. WE COULD NOT RETRIEVE ANY OF OUR BELONGINGS. THE BIKE THEN BECAME COMPLETELY ENGULFED IN FIRE/FLAMES. WE CALLED 911 EMERGENT. THE BIKE COMPLETELY BURNED TO THE FRAME BY THE TIME THE FIRE DEPARTMENT AND STATE TROOPER ARRIVED AT THE SCENE. SEE ATTACHED PHOTOS. WE HAVE MORE PHOTOS IF NEEDED.

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER GS. THE CONTACT STATED THAT IT REQUIRED FORCE TO STEER THE VEHICLE WHILE DRIVING 50 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V162000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,500.

THE DYNAMIC POWER STEERING UNIT WAS RECALLED AND REPLACED ON 12-15-2010. WHEN A CHECK ENGINE LIGHT CAME ON, I TOOK IT IN TO RIDE NOW POWER SPORTS PHOENIX 17202 N. CAVE CREEK RD. PHOENIX, AZ. 85032. IT ALSO FLASHED ON THE DASH THAT THE DPS UNIT NEEDED CHECKED. ON 6-3-2014 THE MILEAGE ON THE UNIT WAS 12,000. THE DEALER NOTIFIED BRP THAT THIS HAD OCCURRED, CLAIM # 313909. BRP MANAGEMENT SAID THE CAN AM SPIDER WAS OUT OF WARRANTY AND I WOULD HAVE TO PAY THE DEALER TO FIX IT. I WAS TOLD THAT IT WOULD COST APPROXIMATELY $ FOR PARTS PLUS LABOR TO INSTALL. AT $ PER HOUR FOR LABOR, THAT COULD AMOUNT TO A LARGE SUM. THE TECH TOLD ME THAT THE STEERING UNIT WAS WORKING FINE BUT THE SENSOR MALFUNCTIONED AND COULD NOT BE REPAIRED BY ITSELF, DUE TO THE FACT IT WAS SEALED INSIDE THE DYNAMIC POWER STEERING UNIT. THE WHOLE UNIT WOULD NEED TO BE REPLACED AT A COST OF A COUPLE OF THOUSAND DOLLARS TO REPAIR A $ SENSOR. THEY ALSO INFORMED ME THAT IF I CHOSE TO HAVE RIDE NOW SPORTS OF PHOENIX, AZ INSTALL THE NEW DPS UNIT, IT WOULD ONLY CARRY A 90 DAY WARRANTY. WHILE I WAS AT THE SERVICE DEPARTMENT A CUSTOMER WITH A 2014 CAN AM SPIDER CAME IN WITH THE SAME ISSUE ON A NEWER MODEL. THIS REALLY DISCOURAGED ME TO INVEST IN A NEW UNIT TO SOLVE A PROBLEM THAT HASN'T BEEN RECTIFIED BY THE MANUFACTURER. THE WARRANTY ENDED ACCORDING TO BRP ON 11-25-2013. I FEEL THIS IS NEGLIGENT ON THE PART OF THE MANUFACTURER TO NOT HANDLE THIS AT THEIR EXPENSE. PLEASE HELP ME, (THE CONSUMER), IN HOLDING THESE INDIVIDUALS R

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER ROADSTER GS 5S Y (NA). THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE CONTACT NOTICED FUEL FUMES EMITTING FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 09V162000 (STEERING), 12V581000 (FUEL SYSTEM, GASOLINE), AND 12V582000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER GS MOTORCYCLE. THE CONTACT STATED THAT WHILE THE MOTORCYCLE WAS PARKED, IT BEGAN SMOKING. THE VEHICLE SUDDENLY BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

THE BACKREST, WHICH HOLDS THE PASSENGER FROM FALLING OFF THE REAR OF THIS 3 WHEELED MOTORCYCLE, IS MANUFACTURED FROM MATERIALS NOT SUBSTANTIAL ENOUGH TO HANDLE THE STRESS PLACED UPON IT, AND HAS BROKEN ON ONE SIDE. IF THE REMAINING SIDE FAILS THE PASSENGER CAN BE THROUGH FROM THE VEHICLE. IT IS MY BELIEF THAT THIS PRODUCT IS ENGINEERED AND MANUFACTURED IN A MANOR IN WHICH SOMEONE WILL BE CATASTROPHICALLY INJURED OR THE END RESULT WILL BE DEATH IF THIS PROBLEM IS NOT CORRECTED. THIS ISSUE HAS BEEN DISCUSSED IN DETAIL WITH THE REPRESENTING DEALERSHIP AND THE MANUFACTURER BOMBARDIER RECREATIONAL PRODUCTS (BRP) BOTH PARTIES HAVE BEEN REQUESTED TO CORRECT THIS SITUATION, AND BOTH HAVE DECLINED STATING THE FAILING ASSEMBLY IS ?OUT OF WARRANTY? THIS ISSUE SHOULD BE THOROUGHLY INVESTIGATED BY NHTSA. THE WRITER CAN PROVIDE PICTURES AND A VISUAL INSPECTION OF THIS FAILURE AT MY RESIDENCE. *TR

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER GS. THE CONTACT STATED THAT WHILE ATTEMPTING TO DRIVE, THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE POWER STEERING FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.

WHILE RIDING HOME FROM WORK MY REAR LIGHTS SUDDENLY WENT OUT. UPON INSPECTION THE NEXT DAY I FOUND THAT THE RIGHT FENDER SUPPORT HAD CUT INTO THE TAILLIGHT HARNESS CAUSING IT TO GROUND OUT. BOTH FENDER SUPPORTS HAD BEGUN TO SEPARATE TO THE POINT THAT THE REAR FENDER ITSELF WOULD EVENTUALLY COME OFF AND COMPLETELY SEVERING THE TAILLIGHT HARNESS. I TOOK PICTURES AND OPENED A CASE WITH THE DEALER. I WAS REJECTED FOR BEING OUT OF WARRANTY. THEY SAID I SHOULD PURCHASE PART # 219800246 WITH TWO NEW SUPPORTS TO FIX THE PROBLEM, WHICH I DID ALL AT MY COST AND LABOR. A WEBSITE SPYDERLOVERS.COM HAS CASES WHERE BRP HAD FIXED SOME BIKES WITH THIS PROBLEM OUT OF WARRANTY. OTHER INDIVIDUALS THAT ARE MECHANICALLY INCLINED WENT AHEAD AND MADE THE REPAIRS THEMSELVES LETTING BRP OFF THE HOOK. I WAS TOLD BY BRP THAT MY BIKE WAS TOO FAR OUT OF WARRANTY. IF BRP FIXED ONE BIKE THEY SHOULD FIX THEM ALL AND/OR OFFER A RECALL. I SPENT $254 ON PARTS AND 1 1/2HRS. LABOR. I HAVE THE DEFECTIVE FENDER SUPPORTS IN MY POSSESSION FOR INSPECTION AND PICTURES BEFORE THE REPAIR WAS MADE. THE REAR FENDER SUPPORTS ON THESE BIKES ARE A HAZARD WAITING TO HAPPEN. THAT IS WHY BRP CAME OUT WITH PART # 219800246 TO REMEDY THIS DESIGN FLAW ON THEIR BIKES. *TR

TL* THE CONTACT OWNS A 2008 CAN-AM SPYDER ROADSTER GS MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH AROUND A CURVE, THE ENGINE AND POWER STEERING WARNING INDICATORS ILLUMINATED WITH THE LOSS OF POWER STEERING ASSIST. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. THE POWER STEERING WAS RESET UPON RESTARTING THE IGNITION. IN 2010, THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO NHTSA CAMPAIGN ID NUMBER: 09V162000 (STEERING). THE FAILURE RECURRED TWO AND A HALF YEARS LATER. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 9,500.

BIKE WOULD VEER INTO OTHER LANES AT HIGHWAY SPEEDS. DEALERSHIP REPEATEDLY SAID NOTHING WAS WRONG. IN OCTOBER 2010 I GOT A RECALL NOTICE. AFTER REPROGRAMMING MY COMPUTER, STEERING WORKED BUT DPS/ENGINE LIGHT CAME ON CONSTANTLY. DEALER AGAIN REPEATEDLY CAN'T FIND PROBLEM. THEY RESET CODES AND SENT ME ON MY WAY. IN MARCH 2013 AGAIN I TOOK IT TO DEALERSHIP. THIS TIME IT NEEDS A NEW DPS COMPUTER FOR $1200 PLUS LABOR. THEY TOLD ME TO CALL BRP TO SEE IF THEY WILL PAY FOR NEW COMPUTER. BRP CASE #4090722. I JUST GET THE RUN AROUND. TOO BUSY TO GET TO IT NOW. THE DEALER SHOULD HAVE FIXED IT THE FIRST TIME. EXCUSES! IT IS STILL AT THE DEALERSHIP 3 WEEKS LATER, WITH NO END IN SIGHT. MY BIKE HAS A TOTAL OF 4000 MILES ON IT BECAUSE I MIGHT GET KILLED WITH THIS PROBLEM. I AM AFRAID TO DRIVE IT. *TR

SINCE PURCHASING BRAND NEW IN 2008, THIS UNIT HAS HAD TERRIBLE GAS FUMES WHEN RIDING, AND A TERRIFIC BUILDUP OF RAW GAS FUMES IN THE GARAGE UPON PARKING. THIS HAS BEEN AN ONGOING PROBLEM. SEVERAL TRIPS TO THE (NOW DEFUNCT) DEALER, VISITS TO DIFFERENT DEALERS, SEVERAL E-MAILS TO BRP IN CANADA, AND NO SOLUTIONS. NOBODY WANTS TO ADDRESS THIS PROBLEM, AND MOST OWNERS OF THESE MOTORCYCLES HAVE THE SAME COMPLAINT: GAS SMELL, CARBON MONOXIDE, LACK OF DEALER SUPPORT, AND NO SOLUTIONS. IT IS NOT RIGHT THAT EVERY TIME WE RIDE OUR MOTORCYCLE, WE GET HEADACHES AND OUR CLOTHING STINKS LIKE GAS FUMES AND EXHAUST. THIS IS AN UNHEALTHY, DANGEROUS SITUATION, WHICH NEEDS YOUR ATTENTION. THIS MOTORCYCLES HAVE A DESIGN PROBLEM THAT IS BEING IGNORED BY CAN-AM (BRP). THANK YOU VERY MUCH FOR YOUR HELP! *TR

MY 2008 CAN AM SPYDER WAS PARKED WITH THE EMERGENCY BRAKE ON. THE VEHICLE ROLLED DOWN MY DRIVEWAY NARROWLY MISSING MY CHILDREN AND IT FINALLY CAME TO REST IN MY NEIGHBORS FENCE. I HAVE TAKEN THE VEHICLE INTO THE DEALER 4 TIMES NOW FOR THE EMERGENCY BRAKE NOT HOLDING AND THE VEHICLE ROLLING BACKWARDS OR FORWARDS. THE VEHICLE HAS NO WARNING SYSTEM TO TELL YOU THE BRAKE IS NOT HOLDING. THIS IS THE ONLY THING THAT HOLDS THIS 1000 POUND VEHICLE. *TR

ON MULTIPLE OCCASION DUE TO THE PROBLEMS WHILE TRAVELING AT HIGHWAY SPEEDS THE VEHICLE LOST POWER AND I WAS NEARLY REAR ENDED. AS OF 5/1/12 BRP HAS FAILED TO RETURN MY EMAILS ALL REPAIRS INCLUDING TOWING HAS BEEN PAID OUT OF POCKET AND THE BIKE IS UNDER WARRANTY UNTIL 2013. *TR

CONSUMER WRITES REGARDING RECALL ON CAN-AM BOMBARDIER SPYDER CONCERNING THE COMPUTER SOFTWARE *TGW THE CONSUMER STATED HE RECEIVED ANOTHER RECALL REGARDING THE POWER STEERING UNIT. THE CONSUMER STATED HE HAS BEEN UNSUCCESSFUL AT GETTING THE RECALLS TAKEN CARE OF. THE POWER STEERING UNIT MALFUNCTIONED WHICH CAUSED THE MOTORCYCLE TO VEER INTO ONCOMING TRAFFIC. *JB

I RIDE A CAN AM SPYDER WHICH IS A 3 WHEELED MOTORCYCLE AND ON 8-8-10 IT SPONTANEOUSLY CAUGHT ON FIRE, THANK GOODNESS SOMEONE WAS ABLE TO GET A FIRE EX. AND PUT OUT THE FIRE BUT NONE THE LESS IT MELTED A LOT OF PARTS. IT IS NOW AT A DEALER WAITING FOR PARTS TO COME IN THE BE REPLACED. I HAVE READ ON SEVERAL WEB SITES THAT THIS HAS HAPPENED BEFORE, MAYBE A RECALL IS IN ORDER. NO ONE WAS HURT. *TR

THREE WHEELED CYCLE STEERING LOCKED/BINDED AT ABOUT 45 MPH. OPERATOR LOST CONTROL AND RAN OFF THE ROAD CAUSING PROPERTY DAMAGE. THIS WAS THE FOURTH TIME THE STEERING "BINDED" WHILE TRAVELING STRAIGHT AT FREEWAY SPEEDS. *TR