2015 BMW 640i

Defect. BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo, and 2015 4 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.

Remedy. The driver's front air bag will be replaced, free of charge. Owner notification letters were mailed September 6, 2024. Owners may contact BMW customer service at 1-800-525-7417.

The car is leaking from the third rear brake light (at the rear roof of the car). It appears the seals and possible clips/fasteners have failed and water is entering the car during rain or water immersion from the rear brake light, to the back seat, trunk, and rear floor. There is now visible mold in the car.

THE REAR TIRE WAS LEAKING CAUSING AN UNSAFE ROAD CONDITION. WHEN THE TIRE WAS INSPECTED IT WAS FOUND THAT THE WHEEL HAD A CRACK IN THE SUPPORT DUE TO A DEFECT IN DESIGN. THE DEALER STATES THAT MANY OF THE 5 AND 6 SERIES WITH THIS WHEEL HAVE ISSUES AND OFFERED ME A "WARRANTY PACKAGE" FOR THEM FOR $1700. WHEN DOING RESEARCH ONLINE THIS IS A COMMON PROBLEM AND A CLEAR SAFETY ISSUE. WHEN USED WITH RUN-FLATS (WHAT THEY SUGGEST AND REQUIRE) THE WHEEL TAKES TOO MUCH STRESS AND ULTIMATELY CRACKS. MY VEHICLE HAS LESS THAN 25,000 MILES ON IT AND IT HAS A CRACKED WHEEL WITH NO REASON. THIS IS A CLEAR SAFETY CONCERN AS A RAPID LOSS OF AIR IN A WHEEL MAY CAUSE LOSS OF CONTROL. IT HAS CLEAR CONCERNS FOR STOPPING DISTANCE AND AVOIDANCE AS WELL.

THE TIRES BLEW OUT WHILE ON A ROAD TRIP AT APP 11,000 MILES, SEPARATION RIGHT UNDER THE RIM. TIRES ARE STILL UNDER WARRANTY. HOWEVER, GOODYEAR DUNLOP WON'T BE SQUARE WITH WARRANTY, MAKING THE WARRANTY OF NO VALUE. IN FACT THEY LIED ABOUT THE CAUSE AT FIRST. STILL HAVE THE TIRE FOR REVIEW.

DRIVERS SIDE DOOR OPEN ON ITS OWN, WILL NOT STAY SHUT , DEALSHIP HAS BEEN UNABLE TOO FIX IT? SIDE DOOR DOESN'T CLOSE REPAIRED FOUR TIMES . ENGINE LIGHT COME ON? ROOF LATCH NO AIR BAGS WENT OF?DEALSHIP SAYS CODES SAY?THEY DID?