2012 BMW 550i

Defect. BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.

Risk. If the circuit board were to overheat, it can increase the risk of a fire.

Remedy. BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Risk. The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy. BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

I was driving when the vehicle engine randomly shut down with out warning I was on the freeway at the time and could have been hit by a car. I took thr car to an auto repair shop, had the problem inspected snddiagnosed and was told the engine was faulty. I had the engine replaced and the same issue occurred. There were no warning lamps, messages, or alerts prior to the problem occurring. The drivetrain malfunction light came on as soon as the engine cut off.

The contact owns a 2012 BMW 550i. The contact stated after parking and exiting the vehicle, he noticed coolant leaking on the front driver’s side and saw white smoke exiting near the water pump. The contact stated the low coolant fluid and the drivetrain malfunction warning lights were illuminated. The contact stated the smoke disappeared on its own. The contact stated that he continued driving the vehicle. The contact took the vehicle to an independent mechanic and was informed that the water pump needed to be replaced. The vehicle was not repaired. The contact took the vehicle to the local dealer, where it was diagnosed with needing the water pump to be replaced. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 60,000.

My car died in an intersection unexpectedly as if my battery had died. My infant was in the backseat. This was suck a busy intersection that police dept had to park behind me to keep me from being hit. The car could not be put in neutral to move it out of the way. After over an hour we were able to restart the car and excessive battery discharge message displayed. This is on top of me taking it to the dealership for excessive oil consumption and BMW was aware my motor would eventually give out.

Engine is available for inspection upon request. Earlier this month, my 550i completely shut off at a traffic light. When attempting to restart the engine, the Starter strained very hard and smoke came out of the engine. Engine was immediately shut off and the car was towed to a local shop. In turn the shop replaced the Starter the following day and heard knocking from the engine once it turned it over. Upon examination the shop pulled open the oil filter and it was full of metal shrapnel. I feel fortunate the car was not in motion at the time of the failure, given the engine shut off with no warning this could have resulted in a catastrophic accident.

2012 F10 had issues while running as car installed and stopped completely multiple times in traffic. Fuel supply sign came on. Diagnosed as low pressure fuel pump degraded and need replacement. Same recall took place for 2007-2011 5 series model as well via recall campaign No. 16v-746: In-Tank Fuel Pump. 2012 have same issue and very dangerous to drive on road when vehicle stalls and stops while driving in traffic

THE HIGH PRESSURE FUEL PUMP CAUSED A FIRE IN THE ENGINE COMPARTMENT AND TOTALED THE CAR WITH LESS THAN 60K MILES ON IT

TL* THE CONTACT OWNS A 2012 BMW 550I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVETRAIN MALFUNCTION WARNING LIGHT APPEARED ON THE INSTRUMENT PANEL. THE CONTACT ALSO NOTICED THAT THE WARNING LIGHT WAS ILLUMINATED UPON DEPRESSING THE ACCELERATOR PEDAL. THE CONTACT ALSO STATED THAT THE VEHICLE HESITATED WHEN THE FAILURE OCCURRED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED A SINGULAR COIL AND A SPARK PLUG. TWO MONTHS LATER, THE SAME FAILURE RECURRED AND THE CONTACT TOOK THE VEHICLE BACK TO THE INDEPENDENT MECHANIC WHERE THEY REPLACED ALL THE COILS AND SPARK PLUGS. UPON RETURN OF THE VEHICLE, THE CONTACT WAS DRIVING HOME AND THE VEHICLE SHUT-OFF WITHOUT WARNING. THE VEHICLE WAS TOWED BACK TO THE SAME INDEPENDENT MECHANIC. UPON FURTHER INSPECTION OF THE VEHICLE, THE MECHANIC DETERMINED THAT THE OIL PUMP TIMING CHAIN WAS LOOSENED AND NEEDED TO BE REPLACED. UPON INVESTIGATION, THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VEHICLE WAS NOT INCLUDED. THE CONTACT REACHED OUT TO A DEALER AND WAS INFORMED THAT A DIAGNOSTIC NEEDED TO BE PERFORMED TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT DECLINED THE DIAGNOSTIC TEST. THE CONTACT ALSO EMAILED THE MANUFACTURER WHO INFORMED HIM TO TAKE THE VEHICLE TO A LOCAL DEALER FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.

VEHICLE STOPS SUDDENLY WHILE DRIVING

TL* THE CONTACT OWNS A 2012 BMW 550I GRAN TURISMO. THE CONTACT STATED THAT WHILE HER SON WAS DRIVING AT 45 MPH, THE VEHICLE LOSS POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS PULLED TO THE SIDE OF THE ROAD AND RESTARTED. THE VEHICLE JERKED. THE VEHICLE WAS TAKEN TO THE CLASSIC BMW LOCATED AT 6800 DALLAS PKWY, PLANO, TX 75024, (214) 778-2600, WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND THE SPARK PLUGS NEEDED TO BE REPLACED. THE CONTACT WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

TL* THE CONTACT OWNS A 2012 BMW 550I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ALSO STATED THAT ON VARIOUS OCCASION, THE STEERING WHEEL VIBRATED UNCONTROLLABLY WITHOUT WARNING WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT THERE WAS A CLICKING SOUND COMING FROM THE VEHICLE DURING THE STEERING FAILURE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.

WHEN YOU FIRST TURN THE CAR ON IT SOUNDS VERY LOUD FOR ABOUT 5 MINUTES (LOUDER THAN NORMAL). WHEN DRIVING DOWN THE ROAD THE CAR WILL START SHAKING AND THE CAR COMPUTER POPS UP SAYING DRIVETRAIN MALFUNCTION AND YOU HAVE TO PULL OVER TO RESTART. HESITATE BEOFRE TAKING OFF AT A RED LIGHT OR WHEN TURNING IN AN INTERSECTION. COMPUTER ERROR MASSAGE COMES AND GOES.

WHEN DRIVING DOWN THE ROAD THE CAR WILL START SHAKING AND THE CAR COMPUTER POPS UP SAYING DRIVETRAIN MALFUNCTION AND YOU HAVE TO PULL OVER TO RESTART THE CAR. BUT IT DOES IT AGAIN 5-10 MINUTES LATER

WHILE DRIVING ON HIGHWAY A POP SOUND HAPPEN AND CAR STARTED TO DRIVE AND SHACKING OCCURRED AND SHIFTING OF GEARS WAS ERRATIC. TRANSFER CASE FAILED MADE VERY DIFFICULT TO GET OUT OF WAY OF TRAFFIC BIT OF STALL AND HESITATION.

WHEN I PRESS ON THE GAS TO ACCELERATE THE "DRIVETRAIN MALFUNCTION" ERROR COMES ON. MY CAR ONLY HAVE 51,000 MILES. I HAVE TO TURN THE CAR OFF AND WAIT A MINUTE TO RESUME DRIVING.

SON WAS DRIVING CAR AND CAR JUST SHUT OFF IN THE MIDDLE OF THE ROAD WITHOUT ANY WARNING. CAR WAS TOWED TO BMW DEALERSHIP AND THEY WANT TO CHARGE $3000 TO TEAR DOWN ENGINE TO SEE WHY ENGINE LOCKED UP. CAR WAS BOUGHT 31 MAY 2019 AND SHUT DOWN AFTER DRIVING A LITTLE OVER 3,000 MILES 12 OCTOBER 2019. JUST A COMPLETE RUNAROUND WITH BMW OFFICES.

TL* THE CONTACT OWNS A 2012 BMW 5501. WHILE DRIVING APPROXIMATELY 65 MPH, THE "SERVICE REQUIRED SOON" MESSAGE ILLUMINATED ON THE MESSAGE CENTER AND THE VEHICLE STALLED. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER. THE VEHICLE WAS TOWED TO GLOBAL IMPORTS (550 INTERSTATE NORTH PKWY SE, ATLANTA, GA 30339) WHERE IT WAS DIAGNOSED THAT THE ENGINE SEIZED AND A NEW ONE WAS NEEDED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS RUNNING ODDLY APPROXIMATELY A WEEK BEFORE THE FAILURE, PRESUMABLY DUE TO OIL CONSUMPTION ISSUES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 49,479.

CAR WILL STALL JERK AND STALL LOSSES POWER WHILE ACCELERATING.

BMW TEARS UP TIRES CAUSING THEM TO SHREAD WHILE DRIVING DOWN ROAD. AFTER TWO ALIGNMENTS IN A YEAR. NO FRONT END DAMAGE PER BMW.

TAKATA RECALL CAR USES EXCESSIVE AMOUNTS OF OIL, A QUART EVERY WEEK.

TL* THE CONTACT OWNS A 2012 BMW 550I. AFTER DRIVING THE VEHICLE A SHORT DISTANCE, THE CONTACT FELT EXTREME HEAT COMING FROM UNDERNEATH THE VEHICLE AND SMELLED BURNING WIRES. ORANGE COUNTY BMW (101 MAHER LN, HARRIMAN, NY 10926, (845) 782-4269) STATED THERE WERE NO RECALLS AND SCHEDULED AN APPOINTMENT. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 59,287.