2005 BMW 545i

The contact owns a 2005 BMW 545I. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the contact became aware of a ball of white smoke coming from the exhaust. The contact stated that whenever the accelerator pedal was depressed, there was white smoke coming from the exhaust pipe. The vehicle was taken to an independent mechanic where it was diagnosed with a failed crank casting and the protective crank casting valve. The contact was informed that the failure was similar to an undisclosed manufacturer's recall, however the contact's VIN was not associated with the recall. The independent mechanic informed the contact that the smoke was excessive. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 122,195.

The wiring inside of the headlights has dried up and fallen off, leaving bare electrical wire. The resulting was both of the headlights became non operational at night. To replace the headlights in the car with all the factory features is about 3200.00 for parts alone. I know of others who have had this happen, and everyone i know who owns one, has the same exact problem. The vehicle in question barely has 125,000 miles on it. I feel the manufacturer should repair these vehicles at no cost to the owners.

At approxamitately 1:20pm on July 13, after being parked for a little over an hour I was told that my car was burning. 911 was called immediately and the owner of the establishment went outside and called to the firemen at the station on the other side of the street. Their response was immediate. Response was so quick that damage was limited to the right rear. Which seems that the fire started in the area directly foreward and above the battery

WHILE DRIVING TO WORK DURING MORNING RUSH HOUR IN A BUSY HIGHWAY THE CAR JUST STOPPED RUNNING. NO ODD SOUNDS NO SHUTTING NO CLUNKING. IT WAS LIKE SOME JUST TURNED THE KEY OFF. I MADE IT TO THE SIDE OF THE HIGHWAY AND HAD TO WAIT TWO HOURS FOR A TOW TRUCK TO SHOW UP. MOST OF THE WEEK PREVIOUS TO THIS MY CAR WOULD NOT START AT RANDOM TIMES EVEN THOUGH MY BATTERY WAS GOOD AND I HAD GAS. THE PROBLEM WAS THE DME HAD WATER INGRESS FROM A POOR LOCATION WHERE THE DME AND METRONIC COMPUTER AND THE INTERGRADED POWER MODULE ARE LOCATED AND STORED. THEY ARE IN A SEALED PLASTIC BOX UNDER THE CABIN FRESH AIR INLETS AND CABIN FILTERS AND THE FRONT HOOD COWL. I'M THE BOX THERE IS A FAN AT THE BOTTOM TO EXPELL MOISTER. IF THE INTERGTATED POWER MODULE STARTS TO GO THEN THE FAN STOPS WORKING OR THE FAN IT SELF GOES BAD. AT THAT POINT THERE IS ALMOST ALWAYS WATER INGRESS INTO THE DME AND OR THE METRONIC COMPUTER CAUSING THE CAR TO NOT TO RUN OR EVEN CRANK AND WITH WATER CORROSION ON THE THE DME IT CAUSES PHANTOM PROBLEMS IN OTHER AREAS OF THE CAR. THE DME IS ALSO NOT EASILY REPLACED. THE CAR HAD TO BE TAKEN TO THE DEALERSHIP AND THEY HAVE TO ORDER A NEW DME AND ALIGN IT WITH THE BE CAS MODULE FOR THE IMMOBILIZER TO WORK CORRECTLY AND FOR YOUR CAR TO START. THIS USALLY COST IN EXCESS OF $2,000 JUST FOR THE NEW DME. THE WORST PART OF THIS WHOLE THING IS I LOST MY JOB BECAUSE I WAS 4 HOURS LATE TO WORK AFTER WAITING FOR THE TOW AND GETTING A RIDE TO WORK

DRIVING APPROXIMATELY 50 MPH AN ACCIDENT OCCURRED WHERE THERE WAS OIL IN ROAD. MY CAR LOST CONTROL AND VEERED INTO A GUARD RAIL ON THE HIGHWAY. MY CAR WAS SUBSEQUENTLY TOTALED AND NONE OF MY AIR BAGS DEPLOYED IN THE CRASH.

AS I UNDERSTAND A VEHICLE FOR PASSENGER SIDE AIRBAG IN PASSENGER SIDE FREE STREAM HAS BEEN DEALT WITH ALREADY I JUST RECEIVED THIS VEHICLE SEVERAL MONTHS AGO SO IT IS NEW TO ME AND I HAVE THE SAME ERRORS AS WHICH A RECALL HAS BEEN ISSUED FOR MY CAR 2005 545 I BMW. AS I HAVE READ AFTER X AMOUNT OF YEARS A RECALL IS FINALIZED I JUST RECEIVED THIS VEHICLE SEVERAL MONTHS AGO SO I FEEL I AM STILL ABLE TO SUCCEED FROM THIS SAFETY RECALL FROM THE MANUFACTURE

GOOD EVENING ALL, SINCE 2011 I HAVE HAD ISSUES WITH THE I DRIVE SYSTEM. JUST RECENTLY, THE SYSTEM STOPPED WORKING. AFTER ATTEMPTING TO RESOLVE THE ISSUE WITH BMW OF ONTARIO, THEY DECLINED TO COVER THE VEHICLE'S I DRIVE COMPUTER MODULE. FINALLY, THE COMPUTER STOPPED WORKING AND I COULD NOT SEE MY COMPUTER DISPLAY OR LISTEN TO MUSIC. I COULD NOT RE-SET THE AIR PRESSURE ON THE TIRES. I DROVE THE VEHICLE THAT WAY FOR MONTHS. FINALLY, I WENT TO THE JUNK YARD AND FOUND A VEHICLE SIMILAR TO MINE AND REPLACED IT. EVEN THOUGH I REPLACED THE COMPUTER, I WAS NOT ABLE TO GAIN CERTAIN FUNCTIONS ON MY VEHICLE THAT CAME STANDARD WITH THAT PARTICULAR VEHICLE SUCH AS THE SATELLITE RADIO OR SPEAK TO CALL FUNCTION. I'M PRETTY SURE MANY VEHICLE OWNERS CAN RELATE TO THIS ISSUE AND THE DIFFICULTY IT HAS CREATED TO TRY AND MITIGATE WITH THE DEALER. TAKE CARE,

GOOD EVENING SIR, I AM WRITING TO YOU BECAUSE MY VEHICLE HAD BARE WIRES ON THE HEADLIGHT. THE HOT WIRE AND GROUND WIRES WERE TOUCHING. I DID NOT HAVE THE HEADLIGHT WORKING. THERE IS A PROBLEM WITH THE WIRES OF THE VEHICLE PEELING OFF AFTER A CERTAIN AMOUNT OF TIME.

GOOD EVENING ALL, EVERY TIME I FILL UP THE GAS IN THE VEHICLE, THERE IS A STRONG SMELL INSIDE THE CAB. THIS BEGAN OCCURRING ABOUT 4 YEARS AGO BUT HAS CONTINUED THOUGHT MY TIME WITH THE VEHICLE. CURRENTLY, I CANNOT FILL THE TANK AT MORE THAN . IF I DO FILL UP THE VEHICLE TO MORE THAN I FACE HAVING TO SMELL THE FUMES OF THE FUEL INSIDE THE CAB OF THE VEHICLE. THIS IS A SAFETY ISSUE AND SHOULD BE RECALLED. MANY PEOPLE HAVE A SIMILAR COMPLAINT WITH THESE VEHICLES.

CERTAIN BMW MODELS INCLUDING E60 2005 545I ALMOST ALL REQUIRE VALVE SEAL REPLACEMENT DUE TO FAULTY MANUFACTURING DEFECTS. THIS RESULTS IN OIL LEAKING INTO THE ENGINE AND SECONDARY AIR INJECTOR CAUSING SMOKE TO EMIT OUT OF THE TAILPIPES. ALTHOUGH MY CAR PASSED AL COMPUTERIZED SMOG CHECKS, IT DID NOT PASS THE NEW VISUAL TEST BECAUSE OF THESE FAULTY VALVE STEM SEALS. THIS OCCURS AFTE IDLING THE ENGINE FOR 10 MINUTES. THE REPAIR COSTS FOR THIS ARE ABOUT EQUAL TO THE RETAIL VALUE OF THE CAR. EVERY MECHANIC I'VE SPOKEN TO BELIEVES THIS SHOULD BE RECALLED.

TL* THE CONTACT OWNS A 2005 BMW 545I. WHILE THE SEAT HEATER WAS ACTIVATED, THE FRONT DRIVER'S SEAT BECAME EXTREMELY HOT. SMOKE WAS SEEN COMING FROM THE SEAT AND THE RIGHT SIDE OF THE STEERING WHEEL. THE SEAT HEATER WAS TURNED OFF AND THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS CONCERNED THAT THIS COULD CAUSE A FIRE. THE VEHICLE WAS TAKEN TO HABBERSTAD BMW NEW AND PRE-OWNED (945 E JERICHO TURNPIKE, HUNTINGTON STATION, NY 11746 (800) 997-9313) WHERE IT WAS DIAGNOSED THAT THE FAULTY HEATER WIRING, THE SEAT, AND THE STEERING WHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE CONTACT WAS ADVISED NOT TO ACTIVATE THE SEAT HEATER. THE FAILURE MILEAGE WAS 123,000. UPDATED 08/30/17*LJ *TR

I AM WRITING TO YOU TO ADDRESS A CURRENT NATIONAL HIGHWAY TRAFFIC ADMINISTRATION (NHTSA) SAFETY RECALL AFFECTING MY VEHICLE (AND PRESUMABLY MANY SIMILAR VEHICLES). I CURRENTLY OWN A 2005 BMW 545I 4-DOOR SEDAN (VIN: [XXX] WITH 84,474 MILES AND HAVE RECENTLY EXPERIENCED A FRONT PASSENGER SEAT OCCUPANT DETECTION MAT MALFUNCTION. THIS SENSOR MALFUNCTION AFFECTS THE DEPLOYMENT OF THE FRONT PASSENGER SEAT AIRBAG IN THE EVENT OF A COLLISION. THE ERROR CODES MY VEHICLE IS DISPLAYING ARE THE SAME AS THOSE ADDRESSED IN THE NHTSA SAFETY RECALL (NHTSA CAMPAIGN NUMBER 08V384000, DATED 5 AUG 2008) INDICATING A PASSENGER AIRBAG HAS MALFUNCTIONED, "OFF", AND WILL NOT DEPLOY IN THE EVENT OF AN EMERGENCY. THE NHTSA RECALL INDICATED BMW IS RECALLING 2004-06 5-SERIES MODELS (INCLUDING THE 545I) EQUIPPED WITH SEAT TYPES THAT MAY PRODUCE SIMILAR ERRORS DUE TO CRACKING THAT DEVELOPS WITH AGE. FRANKLY, I FIND IT RIDICULOUS THAT OTHER VEHICLES WITH THE SAME YEAR, MAKE, AND MODEL ARE EXPERIENCING THE SAME MALFUNCTIONS AND ERRORS AS MY VEHICLE, HOWEVER, THOSE VEHICLES ARE BEING COVERED UNDER A CURRENT BMW SAFETY RECALL WHILE MY VEHICLE IS NOT. IN THE END, MY PASSENGER AIRBAG WILL NOT DEPLOY IN THE EVENT OF A COLLISION FOR THE SAME MALFUNCTIONING SEAT SENSOR, YET, BMW HAS TURNED A BLIND EYE TO MYSELF AND I PRESUME A LARGE NUMBER OF OWNERS WITH THIS SAME PROBLEM. CAN THE NHTSA ADDRESS THIS ISSUE WITH BMW NA? THANK YOU IN ADVANCE FOR YOUR TIME AND CONSIDERATION REGARDING THIS MATTER. PLEASE FEEL FREE TO C

HELLO SIR OR MA'AM; I AM WRITING TO YOU TO ADDRESS A CURRENT NATIONAL HIGHWAY TRAFFIC ADMINISTRATION (NHTSA) SAFETY RECALL AFFECTING MY VEHICLE (AND PRESUMABLY MANY SIMILAR VEHICLES). I CURRENTLY OWN A 2005 BMW 545I 4-DOOR SEDAN (VIN: [XXX]) AND HAVE RECENTLY EXPERIENCED A FRONT PASSENGER SEAT OCCUPANT DETECTION MAT MALFUNCTION. THIS SENSOR MALFUNCTION AFFECTS THE DEPLOYMENT OF THE FRONT PASSENGER SEAT AIRBAG IN THE EVENT OF A COLLISION. THE ERROR CODES MY VEHICLE IS DISPLAYING ARE THE SAME AS THOSE ADDRESSED IN THE NHTSA SAFETY RECALL (NHTSA CAMPAIGN NUMBER 08V384000, DATED 5 AUG 2008) INDICATING A PASSENGER AIRBAG HAS MALFUNCTIONED, "OFF", AND WILL NOT DEPLOY IN THE EVENT OF AN EMERGENCY. THE NHTSA RECALL INDICATED BMW IS RECALLING 2004-06 5-SERIES MODELS (INCLUDING THE 545I) EQUIPPED WITH SEAT TYPES THAT MAY PRODUCE SIMILAR ERRORS DUE TO CRACKING THAT DEVELOPS WITH AGE. FRANKLY, I FIND IT RIDICULOUS THAT OTHER VEHICLES WITH THE SAME YEAR, MAKE, AND MODEL ARE EXPERIENCING THE SAME MALFUNCTIONS AND ERRORS AS MY VEHICLE, HOWEVER, THOSE VEHICLES ARE BEING COVERED UNDER A CURRENT BMW SAFETY RECALL WHILE MY VEHICLE IS NOT. IN THE END, MY PASSENGER AIRBAG WILL NOT DEPLOY IN THE EVENT OF A COLLISION FOR THE SAME MALFUNCTIONING SEAT SENSOR, YET, BMW HAS TURNED A BLIND EYE TO MYSELF AND I PRESUME A LARGE NUMBER OF OWNERS WITH THIS SAME PROBLEM. CAN THE NHTSA ADDRESS THIS ISSUE WITH BMW NA? THANK YOU IN ADVANCE FOR YOUR TIME AND CONSIDERATION REGARDING THIS MATTER. PLEASE FEEL FREE T

MY PASSENGER SIDE AIR BAG LIGHT AND SEAT BELT LIGHT ARE BOTH ON AT ALL TIMES. THE ON BOARD COMPUTER SAYS FAULT IN PASSENGER SIDE SEAT BELT OR SEAT BELT TENSIONER. ALSO THE BACK BRAKES DON'T WORK AT ALL BUT THE FRONT ONES DO. WAS WONDERING IF THIS WAS A RECALL MATTER BEFORE I SPEND THOUSANDS TO FIX THE PROBLEM

TL* THE CONTACT OWNS A 2005 BMW 545I. WHILE DRIVING APPROXIMATELY 30 MPH, THE PASSENGER SIDE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE SENSOR, BUT THE FAILURE RECURRED AFTER TWO WEEKS. THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT ABOUT AN AIR BAG RECALL AND REFERRED THE CONTACT TO NHTSA. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REMEDIED. THE RECALL DETAILS WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.

PASSENGER AIRBAG RESTRAIN SYSTEM, STATIONARY CITY STREET

THE FRONT AIRBAG SENSOR HAS MALFUNCTIONED, THIS IS A HUGE SAFETY HAZARD THAT HAD A RECALL AND SHAME ON BMW FOR NOT COVERING THIS FOR THE LIFE OF THEIR VEHICLES. GOD FORBID SOMEONE GETS HURT BECAUSE THEY COULD NOT AFFORD TO PONY UP THE $1300 TO FIX THIS SHODDY PART

HEADLIGHT WIRES ARE ALMOST BARE, AND COULD POSSIBLY SPARK AND CAUSE A FIRE.

WHEN THE VEHICLE IS TURNED ON AND WHILE DRIVING, IT SAYS PASSENGER AIR BAG MALFUNCTION BECAUSE OF SEAT BELT TENSIONER OR SOMETHING ELSE. AND WON'T TURN OFF

MY CAR HAS THE LIGHT ON FOR AIRBAG AND SEAT BELT DO TO MALFUNCTION OF SEAT PAD SENSOR IN PASSENGER SEAT.CALLED BMW OF AMERICA, AND WAS TOLD THAT MY CAR IS NOT COVERED UNDER THE RECALL.WOULD APPRECIATE YOU LOOKING INTO THE MATTER .THANKS IN ADVANCE.

2005 BMW 545I E60 FAULT IN PASSENGER RESTRAINT SYSTEM: THIS MODEL BMW HAS EXPERIENCED A FAULT IN THE PASSENGER RESTRAINT SYSTEM AND IS NOT LISTED IN THE PAST RECALL WHICH CAN LEAD TO DANGEROUS SITUATIONS IF AN ACCIDENT OCCURS AND THE RESTRAINT SYSTEM MALFUNCTIONS. THE PROBLEM IS IN THE MAT OF THE PASSENGER SEAT AND UPON A PASSENGER GETTING INTO MY CAR ABOUT A YEAR AGO, I RECEIVED THE ERROR MESSAGE. I SPOKE WITH VARYING BMW DEALERSHIPS (IN DIFFERENT STATES) AND RECEIVED MIXED INFORMATION FROM THE RECALL WASN'T APPROVED YET TO THE CURRENT VERSION OF NO RECALL AND I WOULD HAVE TO PAY THE FULL REPAIR COSTS. SPEAKING WITH BMW OF USA, THERE WAS APPARENTLY AN EXTENDED WARRANTY ISSUED FOR THIS PROBLEM, BUT THE DEALERSHIP NEVER MENTIONED THIS POSSIBILITY TO ME WHEN SPEAKING WITH THEM. AS OF NOW, THE EXTENDED WARRANTY IS EXPIRED SO SHOULD THIS ISSUE OCCUR ON YOUR CAR TODAY - YOU ARE RESPONSIBLE FOR THE FULL COST OF THE REPAIR WHICH IS IN EXCESS OF $1000 AND ADDITIONAL DIAGNOSTIC FEES. THERE IS A VAST AMOUNT OF INFORMATION ON THE POOR QUALITY OF THE PASSENGER SEAT MAT USED BY BMW IN THESE MODELS LEADING TO THIS MALFUNCTION. CAN SOMEONE PLEASE EXPLAIN WHY THE E60 BMW MODELS WERE NOT COVERED IN THE RECALL WHEN THEY ARE EXPERIENCING THE SAME EXACT ISSUE AS OTHER MODELS THAT WERE COVERED? THIS CAN GET SOMEONE SERIOUSLY HURT AND BMW IS PLACING THIS RESPONSIBILITY BACK ON THE CONSUMER WHEN THEY ARE AT FAULT. THIS ISSUE CLEARLY SPANS MANY MORE BMW MODELS THAT WERE LISTED IN THE RECALL AND CONS

FRONT OCCUPANCY SEAT SENSOR MAT. THIS IS UNDER CAMPAIGN ID 08V384000. MY MAKE AND MODEL PLUS YEAR IS INCLUDED IN THIS. A CALL TO BMW STATES THAT MY CAR IS NOT IN THIS RECALL.

BOUGHT MY TIRE IN FEBRUARY OF 2015. HAD ISSUE IMMEDIATELY WITH IT DEFLATING ON ITS OWN WITH NO NOTICEABLE LEAKS. TOOK TO TIRE STORE I BOUGHT FROM THEY FOUND NO ISSUES. PUT INFLATE A TIRE IN IT AND SEEMED TO HELP FOR 2 MONTHS. DRIVING DOWN THE ROAD THE OTHER DAY MY TIRE SHREDDED AND THE TREAD ALMOST CAME OFF THE WHEEL. GOT THE SAME TIRE ON OPPOSITE BACK WHEEL, HAVE NO ISSUES AT ALL WITH IT.

I STARTED HAVING PROBLEMS SEVERAL MONTHS AGO THAT HAS PROGRESSIVELY GOTTEN WORSE. WHEN I ACCELERATE FROM A STOP, IT APPEARS THAT THE AUTOMATIC TRANSMISSION IS STRUGGLING TO GET TO THE NEXT GEAR. THE RPMS WILL FLUCTUATE UP AND DOWN AND SOMETIMES REV WAY UP BEFORE THE CAR KICKS LIKE I HAVE BEEN HIT. IF I TRY TO ACCELERATE FAST FROM A STOP, THE ENGINE WILL REV UP TO ABOUT 5K RPM AND STOP RESPONDING UNTIL I LET OFF THE GAS AND LET THE RPMS DROP DOWN AND THEN IT WILL KICK INTO GEAR. IF I SLOW DOWN TO ALMOST A STOP AND THEN ACCELERATE IT WILL MOST CERTAINLY KICK, SO I HAVE TO BE VERY CAUTIOUS. I HAVE TO MAKE SURE I HAVE PLENTY OF ROOM WHEN PULLING OUT OF AN INTERSECTION BECAUSE I NEVER KNOW WHEN IT WILL ACT UP (WHICH IS MOST OF THE TIME) AND HINDER MY ACCELERATION. ONCE I GET UP TO CRUISING SPEED (ABOVE 45 MPH) IT RUNS SMOOTHLY, BUT IT HAS GOTTEN TO THE POINT THAT I DREAD EVERY TIME I HAVE TO STOP AT AN INTERSECTION OR SLOW WAY DOWN. I TALKED TO THE DEALER AND SAID IF IT WAS THE TRANSMISSION THEN THE SERVICE LIGHT WOULD COME ON. HE ASKED ME WHAT KIND OF GAS I USE AND I SAID SHELL HIGH OCTANE AND HE SAID THAT IS GOOD. OTHER THAN THAT, HE DIDN'T TELL ME MUCH MORE. I WANT TO SELL THE CAR NEXT SPRING BUT WHO WILL BUY IT WITH IT PERFORMING THIS WAY?

I TURNED ON MY CAR AND A NOTIFICATION APPEARED ON THE IDRIVE THAT THERE WAS A PASSENGER RESTRAINT SYSTEM FAILURE. I READ THAT THERE WAS A RECALL ON THIS AND CALLED MY LOCAL BMW DEALERSHIP TO GIVE THEM MY VIN TO SEE IF MY VEHICLE WOULD BE ON THE RECALL. I FOUND OUT THAT IT WAS NOT. I DON'T KNOW WHAT FITS THE CRITERIA FOR THE RECALL AND IF THIS WOULD BE CONSIDERED NORMAL WEAR AND MAINTENANCE OF THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, THE AIR BAG AND SEAT BELT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT CENTRAL MAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER 08V384000 (AIR BAGS) HOWEVER, THE VIN NUMBER WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG SENSOR ILLUMINATED INDICATING THAT THE AIR BAG WAS OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS NOT ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED YET. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

FOR MANY YEARS, AND AFTER MANY "REPAIRS" MY 2005 BMW 545I, WHICH I BOUGHT NEW, HAS NEVER RUN RIGHT. BMW IS AWARE OF THE PROBLEM, DOES ACKNOWLEDGE THAT IT IS AN ISSUE, BUT HAS BEEN UNABLE TO REPAIR IT. I HAVE SPENT MANY THOUSANDS OF DOLLARS IN SEARCH OF A PERMANENT FIX, BUT THE LAST BMW DEALER I DEALT IS MIFFED ON SOLVING THE PROBLEM. WHEN APPROACHING BETWEEN 25-35 MPH, THE TRANSMISSION "SLAMS" AND FEELS LIKE YOU HAVE BEEN REAR-ENDED. IT IS A CONTINUOUS PROBLEM. I HAVE TO SLIGHTLY LET UP ON THE GAS IN THESE SPEEDS IN ORDER FOR THE CAR TO RUN RIGHT WITHOUT AN EMERGENCY LIGHT COMING ON SAYING "TRANSMISSION FAULT; DRIVE MODERATELY." THIS CAN BE A DANGEROUS SITUATION BECAUSE THE CAR IS SENSING THE FAULT AND IT WILL NOT ALLOW ONE TO DRIVE MUCH ABOVE 50 MPH WITHOUT STRAINING THE ENGINE. GOING DOWN THE HIGHWAY AT 50MPH IN MY AREA CAN BE A HAZARDOUS ACTIVITY! THIS HAS BEEN A CONTINUOUS SITUATION WITH THE CAR SINCE I PURCHASED IT UP AND THRU THE PRESENT DATE, AUG, 21, 2014. I HAVE NO FAITH IN THE ENGINE/POWER TRAIN/TRANSMISSION. THIS IS MY FIRST AND LAST BMW. *TR

AS SOON AS I STARTED THE CAR, THE PASSENGER SEAT BELT RESTRAINT AND AIRBAG LIGHT SHOWED UP AS A MALFUNCTION. AFTER DOING SOME RESEARCH I NOTICE THAT BMW HAD A RECALL ON A SEAT MAT SENSOR ON 200,000 5 SERIES. I ALSO DID SOME RESEARCH AND NOTICE THAT THERE IS A GREAT AMOUNT OF PEOPLE WITH THIS SAME PROBLEM. THIS IS A MAJOR CONCERN BECAUSE THE SEAT MAT SENSOR IS BAD THE PASSENGER AIRBAG WILL NOT DEPLOY IF I GET INTO A CAR ACCIDENT. *TR

I BOUGHT MY 2005 BMW 545I AFTER A WEEK MY SEATBELT AND AND AIRBAG LIGHTS WILL NOT GO OUT, EVEN WITH SEATBELT LOCKED IN, IS THERE A RECALL SO I CAN GET THIS FIX AND FEEL SAFE WHEN DRIVING MY CAR. *TR

TL*THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN RECALL NUMBER: 13V564000 (AIR BAGS) BUT WAS ADVISED BY THE DEALER THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE NOTICE SEVERAL MONTHS AGO. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE RECALL REPAIR WOULD BE PERFORMED. THERE WERE NO FAILURES AT THIS TIME.

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE PULLING INTO HIS DRIVEWAY AT UNKNOWN SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

PASSENGER SIDE AIRBAG FAULT LIGHT STAYS ON. DEALER SAID PROBLEM WASN'T UNDER WARRANTY. INFORMATION I FOUND ON THE INTERNET AND BMW SITES SAY IT IS UNDER WARRANTY. I AM AFRAID IF I'M IN AN ACCIDENT, MY PASSENGER COULD BE SERIOUSLY INJURED, OR KILLED. *TR

I TURNED MY CAR ON AND IT IMMEDIATELY WARNED ME THAT MY LEFT READ BRAKE LAMP WAS NOT FUNCTIONING. TO BE SPECIFIC, THERE WERE FOUR WARNING LIGHTS ON: ONE FOR THE REVERSE LIGHTS, ONE FOR THE BRAKE LAMP, AND TWO OTHER ONES. ALL FOR THE LEFT LIGHT. I OPENED IT UP AND IMMEDIATELY OBSERVED THAT THE WIRING HARNESS PLUG WHERE THE WIRING MEETS THE BULB HOLDER HAD SHORTED AT THE GROUND WIRE. THE TWO PIECES WERE MELTED TOGETHER, SUGGESTING THERE MAY HAVE BEEN A SMALL FIRE. BITS OF MELTED PLASTIC FELL ALL OVER THE PLACE WHEN I MANAGED TO FINALLY PULL OUT THE PLUG. *JB

I WAS JACKING UP MY BMW IN MY GARAGE USING A PROPER FLOOR JACK ON THE RIGHT SIDE REAR JACKPOINT STAND BUILT TO JACK THE CAR UP FROM THE RIGHT REAR. THE JACKPOINT FAILED AFTER IT WAS APPROXIMATELY 6 INCHES OFF GROUND, AND THE VEHICLE DROPPED BACK TO THE FLOOR WHERE THE ENTIRE JACKPOINT WAS NOW COLLAPSED INSIDE OF THE FRAME. I CONTACTED BMW DEALER IN CHAPEL HILL,NC, AND ALSO BMWNA WHO OPENED A CASE UNDER MY VIN NUMBER, AND HAD ME BRING THE VEHICLE INTO THE DEALER FOR AN INSPECTION, AND THAT THEY WOULD LOOK THINGS OVER, AND CORRECT THE SITUATION. THE DEALER TOOK 4 WEEKS TO GET BACK, AND TOLD ME THEY NEEDED TO SEE THE CAR AGAIN TO TAKE PHOTOS, AND LOOK IT OVER AGAIN SO I TOOK IT BACK TO THE SAME DEALER IN CHAPEL HILL, NC (PERFORMANCEBMW). THEY TOOK ANOTHER 4 WEEKS, AND ASKED IF I COULD BRING IT BACK AGAIN AS THEY NEEDED A SPECIALIST WHO TRAVELS TO THE DEALERSHIP TO LOOK OVER THE VEHICLE, AND SO I TOOK IT IN AGAIN A 3RD TIME. I THOUGHT FINALLY THEY WOULD RESOLVE THIS ISSUE, BUT AFTER THE 3RD VISIT THEY HAVE NEGLECTED TO CONTACT ME BACK, AND UPON MYSELF CONTACTING THEM 2 -3 WEEKS AFTER THE VISIT I WAS TOLD IT WOULD NOT BE COVERED ,AND THAT BMWNA WOULD TAKE NO FURTHER ACTION INTO REPAIRING MY VEHICLE. THIS IS A HUGE SAFETY ISSUE WHICH I HAVE READ HAS HAPPENED TO OTHERS, AND THEIR IS ABSOLUTELY NO RUST ON THE UNDERSIDE OF MY CAR, AND IT WAS NOT IN AN ACCIDENT. THE FRAME DID NOT HAVE ANY DAMAGE WHATSOEVER UNTIL THIS JACKPOINT FAILURE, AND NOW THEY JUST WANT TO NOT RETURN MY CALLS, AND

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. AFTER REPEATED ATTEMPTS AND FULL BODILY FORCE, THE VEHICLE THEN CAME TO A STOP.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE BRAKE VACUUM PUMP WOULD NEED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 10V446000 (SERVICE BRAKES, HYDRAULIC) BUT WAS ADVISED THAT THE VIN WAS INELIGIBLE UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

MY CAR HAVE AN OVERHEATED CABLE CONNECTION AND IS CAUSING INCREASED ELECTRIC RESISTANCE, WHICH IS A RECALL AND ALSO THE PASSENGER AIRBAG LIGHT IS ON AND BMW REFUSE TO FIX THE ISSUES.. THEY SAY MY VIN WASN'T ONE OF THE CAR THAT'S IN THEIR DATABASE FOR THE RECALLS........ *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING DEACTIVATED WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER RESTARTING THE VEHICLE, ALL OF THE WARNING LAMPS ILLUMINATED AND AN ELECTRONIC MALFUNCTION WARNING MESSAGE SHOWED UP BEFORE THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE 120,000. *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE WAS 99,500 AND THE CURRENT MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE FRONT PASSENGER SEAT ENTRY MAT WOULD NEED TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) THAT HOWEVER, THE MANUFACTURER ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

UPON TURNING ON VEHICLE I DRIVE SAID PASSENGER RESTRAINT SYSTEM MALFUNCTION. I CALLED BMWNA AND THEY SAID THAT THERE WAS NO RECALL, SO I DID SOME RESEARCH AND FOUND THIS WEBSITE HTTPS://WWW-ODI.NHTSA.DOT.GOV/VEHICLECOMPLAINT/INDEX.XHTML STATING THAT MY VEHICLE SHOULD BE COVERED AND I AGREE SINCE THIS WOULD BE CONSIDERED A SAFETY ISSUE. *TR

GOT INDICATION PASSENGER AIR BAG/ RESTRAINT SYSTEM MALFUNCTION ON IDRIVE. TOOK CAR TO REPAIR SHOP AND I WAS TOLD OCCUPANCY SENSOR IN PASSENGER SEAT WAS BAD. I CHECKED FOR A RECALL FOR THIS VEHICLE WITH BMW. I WAS TOLD NO RECALLS FOR THIS PROBLEM ON THIS VEHICLE WAS COVERED. I CHECKED WITH THE PARTS DEPARTMENT AND WAS TOLD THERE WAS ONLY ONE SENSOR FOR THIS CAR. IF THAT'S THE CASE HOW CAN BMW ONLY COVER 200,00 OF THE DEFECTIVE UNITS AND NOT ALL THAT WERE MADE DURING THIS TIME PERIOD. FURTHER, ON THE ONES THEY DID COVER THEY INCREASED THE WARRANTY PERIOD TO 10 YEARS FROM DATE OF ORIGINAL SALE WITH NO MILEAGE RESTRICTIONS? IT SEEMS TO ME A DEAL WAS MADE WITH THE NTSB TO COVER AT LEAST SOME OF THE DEFECTIVE UNITS BUT NOT ALL. BY EXTENDING THE WARRANTY PERIOD TO 10 YEARS ON THE SAME PART THAT IS USED IN ALL VEHICLES ON THIS CLASS, INDICATES BMW HAS ADMITTED ALL THE PARTS ARE FAULTY. BMW SHOULD INCLUDE ALL VEHICLES THAT USE THIS PART IN THE RECALL, RECALL #08V384000 NOT JUST A LIMITED NUMBER. ACCORDING TO MY RECORDS THIS IS THE SECOND OCCURRENCE OF THIS ISSUE, AND WELL BEFORE 2015 WHEN THE 10 YEAR WARRANTY EXTENSION WOULD HAVE EXPIRED. ALSO THIS INDICATES THE REPLACEMENT SENSOR ARE NOT HOLDING UP WELL. IT IS MY OPINION A PROGRAMMING CHANGE SHOULD BE MADE, WHERE THE ONBOARD COMPUTER, CONTROLLING THE AIR BAG, USES A INPUT FROM A SEAT BELT CONNECT SENSOR TO DETERMINE IF THE PASSENGER SEAT IS OCCUPIED? NOT THE FAULTY MAT IN THE SEAT. *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC: POWER ASSIST VACUUM) AND NOW THE VACUUM PUMP WAS LEAKING. THE BRAKE VACUUM LINE WAS REPLACED, BUT THAT DID NOT PREVENT THE VACUUM PUMP FROM FAILING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO STATED THAT THE VACUUM PUMP WAS NOT COVER UNDER THE RECALL SINCE ONLY THE BRAKE LINE HOSE, BRAKE BOOSTER AND BRAKE CALIBUR WERE LISTED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 77,000.

TL* THE CONTACT OWN A 2005 BMW 545I. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE SENSOR FOR THE FRONT PASSENGER NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPLAIR.THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 97,000.

FREQUENT ELECTRONIC MALFUNCTIONS (AVERAGES 1 PER HOUR). CAR WILL ENGAGE CRUISE CONTROL WITH NO WARNING. OCCASIONALLY WILL INCREASE THE CRUISE CONTROL BY 5 MILE PER HOUR INCREMENTS. WILL RANDOMLY SPRAY & WIPE WINDOWS. FREQUENTLY UNLOCKS DOORS & WILL NOT ALLOW THEM TO BE LOCKED AGAIN UNTIL THE CAR IS STOPPED & TURNED OFF. MAKES FREQUENT EMERGENCY CALLS (OFTEN 3-4 TIMES IN AN HOUR). MOVES & ADJUSTS STEERING WHEEL WHILE DRIVING. ACTIVATES TURN SIGNALS. ACTIVATES 4 WAY FLASHERS. ROLLS UP & DOWN WINDOWS WITH NO WARNING. SOMETIMES WILL GO OUTSIDE TO CAR TO FIND WINDOWS ROLLED DOWN WHILE CAR WAS PARKED. ACTIVATES ALARM SIREN WHILE DRIVING. AND MORE ..... *TR

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE AIR BAG AND SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FRONT PASSENGER AIR BAG SENSOR NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08V384000 (AIR BAGS:FRONTAL). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,200.

CAR SLAMS LIKE YOU JUST GOT REAR ENDED IF YOU SPEED UP WHILE ROLLING AT AROUND 35MPH. THIS IS VERY DANGEROUS AS IT HAPPENS WHEN I'M TRYING TO CHANGE LANES AND SPEED UP. ALSO TRANSMISSION JERKS AS IF YOU ARE MISSING A SPARK OR IT IS TRYING TO FIND A HIGHER OR LOWER GEAR WHILE CRUISING IN TRAFFIC BETWEEN 32-40 MPH. IT JERKS NOTICEABLY WHERE MY SON ASKS WHY ARE YOU DRIVING LIKE THAT. THIS IS TERRIBLE AND NEEDS TO BE DEALT WITH, REGARDLESS WHETHER THE CAR IS STILL UNDER WARRANTY OR NOT. NONE OF THESE INCIDENTS SIGNALS A CHECK ENGINE WARNING. THE BANG AT ROLLING IS ENOUGH TO GIVE ONE WHIPLASH. *TR

FOR THE PAST 2 YEARS I HAVE BEEN HAVING PROBLEMS WITH MULTIPLE FLAT TIRES. THE DEALER KEPT TELLING ME I HAD BAD TIRES AND I BOUGHT NEW TIRES EVERY TIME. THIS YEAR AGAIN I HAVE 2 FLAT TIRES AND NOW THE DEALER IS TELLING ME I HAVE 3 CRACKED RIMS AND 1 BENT RIM. I DID NOT HIT ANYTHING. MY INSURANCE CARRIER STATE FARM TOLD ME THIS IS A PROBLEM WITH BMW WHEELS AND THEY ARE NOT RESPONSIBLE TO FIX. THE DEALER IS SAYING THEY KNOW NOTHING OF A RIM PROBLEM. BUT WHEN I SEARCHED IT ON LINE I FOUND THOUSANDS OF PEOPLE WITH THE SAME ISSUE. THIS IS A HUGE DANGER TO ME AS WELL AS ANYONE ELSE NEAR ME WHEN THESE RIMS AND TIRES FAIL. *JS

AN EXCESSIVELY HARSH 2-1 DOWNSHIFT WHEN DECELERATING TO A STOP, OR TRANSMISSION "BANGS" INTO GEAR WHEN ACCELERATING FROM A FULL OR A "ROLLING" STOP (VEHICLE DID NOT COME TO A COMPLETE STOP). *JS

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT WAS DRIVING 15 MPH WHEN THE AIR BAG RESTRAINT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER CONFIRMED THAT THE PASSENGER RESTRAINT MAT SENSOR MALFUNCTIONED. THE DEALER ALSO CONFIRMED THAT THE VIN FAILED TO QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER:08V384000 (AIR BAGS:FRONTAL). THE MANUFACTURER WAS CONTACTED AND NOTED THE VIN. THE CONSUMER WAS ADVISED AN INVESTIGATION WAS TAKING PLACE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,120 AND THE CURRENT MILEAGE WAS 50,150. UPDATED 05/02/12*BF UPDATED 05/04/12