2008 BMW 535i complaints

DRIVING AT 30MPH,ENGINES POWER SUDDENLY REDUCED,ENGINE MALFUNCTION LIGHT COMES ON . TOOK THE CAR TO BMW FREMONT, THEY FOUND THE INTAKE CAMSHAFT POSITION SENSORS FAULTY.THEY REPLACED CAMSHAFT SENSORS,PULSE GENERATOR,O-RING AND TORQUE SCREW.AS ADVISED BY THE SERVICE AGENT HAD TO DO AN OIL, OILFILTER CHANGE AND FUEL INJECTION SERVICE TO PREVENT DEFAULT ON THE WARRANTY OF PARTS PUT IN. AS THE CAR WAS OUT OF THE WARRANTY PERIOD(EVEN THOUGH IT HAS A VERY LOW MILEAGE OF 18760) SO HAD TO PAY $1235 OUT OF POCKET. AT 19350MILES THE SIMILAR ISSUE CAME UP, TOOK IT BACK TO BMW FREMONT, THEY FOUND FAULTS STORED IN DME,2A7C VARIABLE CAMSHAFT TIMING CONTROL INTAKE COLD START 1 TIME NOT CURRENTLY PRESENT,CLEARED FAULTS AND CUSTOMER TO MONITOR. *TR

I WAS DRIVING MY VEHICLE ABOUT 45 MPH WHEN INSTRUMENT CLUSTER WARNING LAMPS CAN ON AND MY CAR LOST POWER AND STALL WHILE I WAS DRIVE . LUCKILY I WAS ABLE TO AVOID A CRASH AND COAST THE CAR TO SAFE SIDE ROAD UNTIL THE CAR CAME TO A COMPLETE STOP. I TRIED TO RESTART THE VEHICLE BUT IT WILL RUN FOR FEW SECONDS AND DIE, HOWEVER I WASN'T ABLE TO RESTART MY CAR. *JS

IT SAYS RESTRAINT SYSTEM MALFUNCTION. . I'M SCARED TO PUT MY CHILDREN IN THE CAR..THIS IS RIDICULOUS AND THERE ARE PLENTY MORE PROBLEMS. .!!!! THERE NEEDS TO BE RECALL BEFORE SOMEONE IS KILLED. *TR

DROVE CAR FOR APPX 1 MILE. STOPPED FOR 10MINS AT A STORE. WHEN I STARTED IT BACK UP, A FAN WAS LOUDER THAN USUAL. I THEN RECIEVED A HIGH HEAT WARNING TELLING ME TO DRIVE MODERATELY OR RISK OVER HEATING. AFTER A FEW MORE MILES, I RECIEVED A WARNING TO STOP THE VEHICLE IMMEDIATELY DUE TO EXCESSIVE HEAT AND NOT TO OPEN THE HOOD FOR RISK OF BURNS. THE VEHICLE SLOWED TO A CRAWL. LUCKILY I WAS A FEW BLOCKS FROM HOME. NEXT MORNING I TOOK IT TO A NON-BMW SERVICE CENTER WHO SAID THAT THE WATER PUMP MALFUNCTIONED ($950). THERE WAS A RECALL FOR CERTAIN 2008 MODELS FOR THE WATER PUMP. I CONFIRMED WITH BMW THAT THIS MODEL WAS NOT INCLUDED. BASED ON SIMILAR COMPLAINTS ONLINE, I BELIEVE IT SHOULD BE. *TR

PRESSING THE SHIFT (TRANSMISSION) SELECTOR INTO THE REVERSE POSITION, CAUSES THE SHIFTERS ELECTRICAL RIBBON CABLE TO GET PINCHED AND THE LIGHTS IN THE SHIFTER AND SPORT BUTTON FAIL TO WORK ANYMORE. REPOSITIONING OF THIS RIBBON CABLE OR USING A DIFFERENT INSULATION METHOD WOULD SOLVE THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE REAR DRIVER'S SIDE BRAKES FAILED ACCOMPANIED BY THE ILLUMINATION OF THE WARNING INDICATORS. THE FAILURE WAS RECURRING. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 13V407000 (EXTERIOR LIGHTING) BUT DID NOT CONFIRM IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE TURN SIGNAL WARNING LIGHT ILLUMINATED AS THE PASSENGER'S REAR TURN SIGNAL AND REVERSE LIGHT FAILED TO ILLUMINATE. THE CONTACT MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 63,000.

WHILE DRIVING ABOUT 35 MPH ON A BUSY STREET AT RUSH HOUR I PREPARED TO MAKE A RIGHT TURN BY INDICATING. THE FAST TURN SINGLE FLASHING STARTED AND THE COMPUTER SYSTEM IN MY 2008 535I SAID REAR TURN SINGLE MALFUNCTION. I SLOWED TO MY THE TURN AND THE PERSON BEHIND ME SLAMMED ON THEIR BRAKES AND SWERVED TO AVOID HITTING ME AND ALMOST CRASHED INTO THE PERSON NEXT THEM. I DIDN'T REALIZE WHY THIS HAPPENED, SO I PULLED OVER TO CHECK MY LIGHTING SYSTEM AND REALIZED THAT THE RIGHT REAR LIGHTS WEREN'T FUNCTIONING PROPERLY. I OPENED THE REAR BRAKE COMPARTMENT AND SMELLED BURNING MELTED PLASTIC. I DISCONNECTED THE BRAKE LIGHT CONNECTOR AND FOUND THAT IT WAS MELTED. I SEARCHED ONLINE AND FOUND THAT THERE IS A NHTSA RECALL FOR THIS PROBLEM FOR MY YEAR CAR. WHEN I WENT TO BEVERLY HILLS BMW I WAS TURNED AWAY. THEY TOLD ME THAT THERE WASN'T A RECALL THAT COVERED MY CAR. THEY WERE VERY RUDE ABOUT THE WHOLE AND BASICALLY TOLD ME THAT I'D HAVE TO DEAL WITH MYSELF AND COVER THE COSTS. AFTER MORE RESEARCH, I HAVE FOUND MANY COMPLAINTS ABOUT THIS ONLINE: HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=571079 APPEARS TO HAVE BEEN GOING ON FOR A LONG TIME. BUT, BMW HAS BEEN AVOIDING THE SAFETY ISSUE!!! PLEASE FILE A COMPLAINT AND GET THIS SAFETY ISSUE RESOLVED BEFORE SOMEONE DIES AS A RESULT. *TR

TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, SMOKE EMITTED FROM THE OUTSIDE REAR OF THE VEHICLE AND THE ENGINE COOLANT WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN INFORMED THE CONTACT THAT THE REAR PASSENGER'S SIDE TAIL LIGHT WIRES HAD FAILED AND WERE COMPLETELY BURNED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBERS: 13V407000 (EXTERIOR LIGHTING) AND 12E029000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN EITHER OF THE RECALLS. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

DRIVING ON HIGHWAY, PANEL INDICATES THAT THE TEMPERATURE IS HIGH, AND ADVISES TO DRIVE MODERATELY. PULLED OVER ONE LANE. BEFORE BEING ABLE TO PULL OVER COMPLETELY, A NEW INDICATION SHOWS ON THE PANEL, INSTRUCTING THAT THE ENGINE IS OVERHEATED. VEHICLE QUICKLY POWERS DOWN IN THE MIDDLE OF THE HIGHWAY. UNABLE TO PULL OFF TO THE SIDE BEFORE THE CAR IS TRAVELING UNDER 20 MPH. LIMPED TO THE ROAD SIDE WITH OTHER CARS BUZZING BY AT DANGEROUSLY DIFFERENT SPEEDS AS COMPARED TO MY OWN. I WAS FINALLY ABLE TO PULL OFF TO THE SIDE OF THE HIGHWAY WHILE GOING LESS THAN 5 MPH, CAUSING OTHER DRIVERS TO SLAM THEIR BRAKES AND HONK PROFUSELY AT ME. THE DECELERATION HAPPENED VERY QUICKLY. WITH LOTS OF TRAFFIC, THIS CREATED A DANGEROUS AND DIFFICULT SITUATION TO MANAGE IN THE MIDDLE OF RUSH HOUR. THE FACT THAT A CRASH DID NOT OCCUR IS A MATTER OF LUCK. AFTER PULLING OFF TO THE SIDE AND LETTING THE CAR COOL FOR SEVERAL MINUTES, I WAS ABLE TO RESTART AND DRIVE SLOWLY, LONG ENOUGH TO GET OFF THE HIGHWAY AT THE NEXT EXIT, ABOUT 500 FEET AWAY. CALLED FOR A TOW TRUCK. CAR IS NOW AT DEALER. *TR

WHILE DRIVING ON THE HIGHWAY, THE CAR INDICATED AN ENGINE MALFUNCTION AND WITHIN SECONDS THE MESSAGE CHANGED TO ENGINE OVERHEATING AND THAT ENGINE IS OPERATING AT REDUCED OUTPUT. IT ALSO ADVISED TO STOP THE CAR IMMEDIATELY AND CALL THE NEAREST BMW DEALER. I HAD THE CAR TOWED TO A BMW DEALER AND THEY IDENTIFIED ISSUE AS A FAILED WATERPUMP. THE WATER PUMP WAS REPLACED FOR ABOUT $1,400. 3 MONTHS LATER, A SIMILAR ISSUE OCCURRED WHERE ENGINE WAS HAVING ISSUES AND THE MESSAGE SAID THAT THE ENGINE IS OPERATING AT REDUCED SPEED BUT THAT IT IS SAFE TO CONTINUE. TOOK THE CAR BACK TO DEALER AND THEY COULD NOT FIND ANY ISSUES; BUT JUST TO BE SAFE (WHATEVER THAT MEANS) THEY REPROGRAMMED THE BATTERY AND THE BILL WAS $126. AGAIN, WITH NO SPECIFIC ISSUE IDENTIFIED OR RESOLVED. *TR

I JUST HAD TO HAVE MY WATER PUMP AND THERMOSTAT REPLACED ON MY 2008 535I. I WAS TOLD THAT IT HAPPENS SO OFTEN, THEY KEEP THE PART ON THE SHELF! ARE THERE REALLY NO RECALLS ON THIS PROBLEM?? ALSO, MY RIGHT TAIL LIGHT SHORTED OUT. I ASKED THE SHOP WHY...HE SAID THIS ALSO HAPPENS ALL THE TIME. THE WIRES FRY! NOT COOL.I REALLY THINK SOMEONE NEEDS TO INVESTIGATE THIS. WHEN I WAS TOLD THEY REPLACE THEM ALL OF THE TIME, I WAS SHOCKED. THAT COST ME $1102.62 TO FIX. THE GUY WHO TOWED ME SAID HE MAKES SEVERAL TRIPS A WEEK FOR PEOPLE WITH THE SAME PROBLEM. *TR

AS I WAS DRIVING HOME ON THE HIGHWAY MY ENGINE OVERHEATED VERY QUICKLY. IT WENT INTO SERIOUS LIMP MODE AND SLOWED DOWN TO UNDER 30MPH IN THE MIDDLE LANE OF A WIDE FREEWAY. I LET IT COOL FOR OVER 20 MINUTES, AND IT OVERHEATED WITHIN 1 MINUTE OF TURNING IT BACK ON. I HAD TO HAVE IT TOWED TO MY MECHANIC AND HE DETERMINED THE WATER PUMP HAD FAILED. I STARTED DOING SOME RESEARCH ONLINE AND IT TURNS OUT TO BE A VERY COMMON ISSUE. I READ MANY MANY COMPLAINTS OF PEOPLE HAVING ELECTRICAL WATER PUMP FAILURES BEFORE 75,000 MILES. WITHOUT A WATER PUMP YOU MUST HAVE THE CAR TOWED AND ITS A VERY EXPENSIVE FIX. BMW/MINI HAVE HAD MANY CARS WITH PROBLEMATIC WATER PUMPS IN THE PAST AND THEY NEVER DO ANYTHING ABOUT IT. THIS ISSUE NEEDS TO RESULT IN A RECALL. *TR

DRIVING MY DAD TO ER FOR MEDICAL EMERGENCY AND DRIVING WITHIN SPEED LIMIT. CAR BEGINS TO SLOW DOWN ON OWN. COULD NOT GO MORE THAN 5MPH WHEN CAR SHUT DOWN AND STATED ENGINE OVERHEATED. WE WERE STALLED ON BUSY HIGHWAY. ONCE ABLE TO GET SOMEONE TO TRANSPORT MY FATHER TO ER, HAD TO GET CAR TOWED. WATER PUMP HAD TO BE REPLACED FOR NO FAULT OF MINE. MY SISTER ALSO HAS BMW 2008 3 SERIES AND SAME THING HAPPENED TO HER YESTERDAY---STRANDED ON SIDE OF ROAD--WATER PUMP HAD TO BE CHANGED. TOW TRUCK DRIVER STATED HE IS TOWING BMW'S ALL THE TIME WITH MALFUNCTIONING WATER PUMPS. THIS REALLY NEEDS TO BE LOOKED INTO BEFORE SOMETHING BAD HAPPENS TO STRANDED DRIVERS. *TR

SMELL OF GAS FUMES IN CAR WHEN STARTED CAR. GAS AND FUMES INCREASED AS CAR IDLED. INFANT ALSO IN CAR. BEGAN FEELING LIGHTHEADED SO HAD TO ROLL DOWN WINDOWS TO MAKE IT HOME. LATER IN EVENING ENTIRE GARAGE WAS CONSUMED WITH GAS FUMES. SENT CAR TO SHOP. FOUND LEAKING FUEL LINE WITH NO FAULT OF MY OWN. *TR

AIR BAG SENSOR MAT IN THE PASSEBGER SEAT IS CRACKED. THEREFOR THE AIRBAG WILL NOT DEPLOY IN A CRASH. ACCORDING TO MY RESEARCH THIS IS A VERY COMMON PROBLEM IN BMW E60 SEDANS. THERE HAS BEEN A PREVIOUS RECALL TO BMW'S IN EARLIER YEARS. WHY IS IT NOT A RECALL NOW? OBVIOUSLY THIS IS A CRITICAL COMPONENT OF THE SAFETY SYSTEM AND SHOULD BE RECALLED AND FIXED BY THE MANUFACTURER. *TR

2008 535I POWER STEERING PUMP AT 49,560 MILES. I FLUID DRIPPING (BROWNISH-REDDISH) ON MY GARAGE FLOOR AND LOOKED UNDER THE CAR AND NOTICED LEAK DEVELOPED UNDER THE CAR ENGINE LEFT SIDE, SIPPED THRU THE UNDER CARRIAGE COVER PLATE. I CONTACTED BMW DEALERSHIP, SET UP APPOINTMENT FOR SERVICE ANALYSIS. I WAS TOLD BY THE SERVICE REP AND HIS MASTER MECHANIC THAT THEY COULD NOT FIND ANY VISIBLE LEAKAGE AND COULD BE "JUST FROM ANOTHER VEHICLE PARKED ON THE SPOT BEFORE AND JUST "TOP OFF ALL FLUIDS". I INSISTED THAT THE DRIPS WAS ON MY GARAGE CLEAN FLOOR AND UN-SATISFIED WITH THE ANSWER. I TOLD THE SERVICE REP THAT I WILL E-MAIL HIM A PICTURE I TOOK OF THE CARS UNDER CARRIAGE SHOWING THE FLUID DRIPPING. AFTER AN HOUR, HE CALLED AND ADMITTED THAT THE PICTURE HELP THEM TO "TROUBLE-SHOOT" AND THEY UN-INSTALL THE UNDER CARRIAGE COVER PLATE AND FOUND A LEAK ON THE POWER STEERING PUMP (PART COST $1,250.00 NOT INCLUDING LABOR, $1,630.00 TOTAL) AND NEED TO BE REPLACED. FORTUNATELY IT'S ALL COVERED UNDER WARRANTY. THIS COULD HAVE CAUSED TOTAL LOSS OF VEHICLE AND CAUSE ACCIDENT OR EVEN LIVES. *TR

TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE EXHIBITED LOUD POPPING NOISES, SIMILAR TO THE SOUND OF A GUN SHOT. THE CONTACT PROCEEDED TO DRIVE THE VEHICLE AND THE GLASS FROM THE SUNROOF BEGAN TO SHATTER, FALLING OVER HIM WHILE DRIVING. THE CONTACT MOVED OFF THE ROADWAY AND CONFIRMED THAT THE SUNROOF SHATTERED. THE VEHICLE WAS TAKEN TO THE DEALER THE FOLLOWING DAY AND THE CONTACT WAS ADVISED THAT SOMETHING MUST HAVE STRUCK THE SUNROOF TO CAUSE THE GLASS TO SHATTER. THE CONTACT WAS PERSISTENT THAT NOTHING HAD STRUCK THE SUNROOF AND LATER WHILE PERFORMING RESEARCH, HE DISCOVERED THAT MANY OTHER OWNERS OF THE EXACT SAME YEAR, MAKE AND MODEL HAD ALSO ENCOUNTERED THE SUNROOF FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS TO THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 36,500.

WARNING OF REAR LIGHT AND REAR RIGHT BLINKER MALFUNCTION. *TR

RIGHT REAR BRAKE LIGHT FAILURE INDICATOR ON DASH BOARD TURNED ON. INSPECTING THE LIGHT BULBS, ALL SEEMED TO BE IN WORKING CONDITION. FUSES WERE ALSO GOOD. FOUND THE GROUND WIRE PIN AND SOCKET ON THE BULB HOLDER BURNED OUT PRETTY SEVERELY. PROBLEM APPEARS TO BE INTERMITTENT AS THE INDICATOR WOULD TURN ON AND OFF BEFORE EVENTUALLY STAYING ON PERMANENTLY. ALSO, INDICATOR WOULD SHOW TURN SIGNAL FAILURE AT FIRST, THEN BRAKE LIGHT, THEN RIGHT BACK UP LIGHT, THEN ALL THREE. EVENTUALLY IT SETTLED IN ON BRAKE LIGHT ONLY. POTENTIAL FOR ACCIDENTS RELATED TO TURN SIGNALS NOT WORKING AND WARNING OTHER DRIVERS OF BRAKING AND/OR TURNING. ALSO POTENTIAL FOR AN ELECTRICAL FIRE BEGINNING IN THE REAR OF THE VEHICLE CLOSE TO WHERE THE FUEL FILLER CAP IS LOCATED. CHECKING ONLINE FORUMS FOR A REPAIR, IT APPEARS TO BE A COMMON PROBLEM, AND THE SUBJECT OF AN EARLIER RECALL ON OTHER BMW MODELS. *TR

THE WARNING LIGHT CAME ON. THE VEHICLE INFORMATION SYSTEM SAID THE FUEL PUMP WAS MALFUNCTIONING. I TOOK IT TO THE DEALER AND THEY SAID THE FUEL PUMP FAILED. *TR

WHILE DRIVING, THE ENTIRE ELECTRICAL PANEL [SPEEDOMETER, RADIO, DISPLAY SCREEN, ETC.] BEGIN TO CLICK ON/OFF EACH TIME REAPPEARING WITH APPEARED TO BE EVERYTHING BUT ENGLISH. SOON TO FOLLOW, I RECEIVED A WARNING LIGHT INDICATING "ENGINE OVERHEATED", "ENGINE POWER WAS BEING REDUCED", AND "TO STOP THE VEHICLE" WHEN POSSIBLE. UNFORTUNATELY, I WAS IN THE MIDDLE OF TRAFFIC AND COULD NOT IMMEDIATELY PULL OFF TO THE SHOULDER. THE VEHICLE DIDN'T TRAVEL VERY FAR BEFORE COMPLETE ENGINE POWER WAS LOST DUE TO THE POSSIBILITY OF "FIRE RISK" AS INDICATED ON THE PANEL. *TR

THE CAR PULLS HARD TO THE RIGHT AND NOW SHAKES ABOVE 20MPH. *TR

THE ACTIVE STEERING STOPS WORKING WITHOUT WARNING, DRAMATICALLY CHANGING THE HANDLING OF THE CAR. IT RANDOMLY STARTS & STOPS WORKING. THE DEALER FIRST DENIED THAT THERE WAS A PROBLEM, THEN AFTER 3 VISITS "FIXED" IT WITH UPDATED SOFTWARE, BUT THE PROBLEM PERSISTS. I HAVE GONE OFF THE ROAD, BUT NOT HIT ANYTHING...YET. *TR