RE 2004 RSV MILLE FACTORY MOTORCYCLE. 5/10/04 HARD TO SHIFT GEARS AND FIND NEUTRAL BECAUSE THE CLUTCH WAS NOT DISENGAGING FULLY WHILE DRIVING. THEREFORE DIFFICULT TO STOP MOTORCYCLE. DEALER BLED CLUTCH LINE. 7/20/04 ENGINE TURNED OFF WHILE I WAS RIDING AT ABOUT 35-40 MILES PER HOUR AND THE REAR WHEEL UNEXPECTEDLY LOCKED UP. ELECTRICAL WIRE AND CONNECTORS MELTED DUE TO ENGINE HEAT. REPLACE AND REROUTED WIRES. 2/8/05 LEAKING GASOLINE FROM THE FUEL CAP. FUEL CAP WAS REPLACED UNDER WARRANTY BECAUSE IT WAS DEFECTIVE. DEALER FOUND THAT THERE WAS NO REAR BRAKE AND NOTED THIS SPECIFICALLY AS A SAFETY ITEM AND THAT AGAIN THERE WAS VERY LITTLE CLUTCH DISENGAGEMENT. NOTE THE PARAGRAPH ABOVE REGARDING THE CLUTCH. 10/2005 STARTER WAS MELTED AND BATTERY WAS NOT CHARGING. NO REPAIR AFTER 9 MONTHS THOUGH WAS UNDER WARRANTY. POTENTIAL WHEEL SEIZURE WHEN BATTERY FAILS. *NM
2004 Aprilia Rsv Mille
Owners filed 3 complaints about this vehicle with federal regulators, most often about the fuel system, gasoline › delivery › hoses, lines/piping, and fittings. No safety recall has been issued.
| Component | Reports | Crashes | Fires | Injuries | |
|---|---|---|---|---|---|
| Service Brakes, Hydraulic › Foundation Components › Master Cylinder | 1 | 0 | 0 | 0 | |
| Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, and Fittings | 1 | 0 | 0 | 0 | |
| Electrical System | 1 | 0 | 0 | 0 |
What owners reported
Newest filingsI PURCHASED A NEW 2004 APRILIA RSVR FACTORY MOTORCYCLE IN SEPTEMBER OF 2005. THE REAR BRAKE ON THE MOTORCYCLE HAS NEVER WORKED, MEANING THERE IS NO BRAKING EFFECT WHATSOEVER. I HAVE REPEATEDLY CONTACTED THE SELLING DEALER AND THE MANUFACTURER TO RESOLVE THIS PROBLEM. I AM TOLD BY BOTH THERE ARE PARTS TO FIX THIS RATHER SIGNIFICANT SAFETY ISSUE, BUT I CAN NEVER SEEM TO GET THEM. THERE ARE MANY OTHER OWNERS OF THIS MOTORCYCLE WITH THE SAME COMPLAINT.*JB
DT: FUEL LINE QUICKLY DISCONNECTED ON 2004 APRILIA RST FUTURA. CALLER WAS TRYING TO DISCONNECT FUEL LINE. WHEN IT WAS TOUCHED IT FELL APART IN HANDS. BOUGHT NEW METAL, QUICKLY DISCONNECTED FUEL LINE THAT REPLACED THE ONE THAT BROKE.*AK
3 of 3 complaints, reproduced as filed.
Across model years
Worst on record: 2004| Year | Complaints | Recalls | Fires | Deaths | Assessment |
|---|---|---|---|---|---|
| 2004 — this page | 3 | 0 | 0 | 0 | Routine |
| 2003 | 1 | 0 | 0 | 0 | Routine |
Reading this record
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Most recent recall on file: none. Source: NHTSA Office of Defects Investigation.