2014 Aluma 5410t

TL* THE CONTACT OWNS A 2016 (NA) ALUMA UT12 (NA) UTILITY TRAILER. WHILE DRIVING 65 MPH, THE DRIVER SIDE WHEEL FRACTURED. THE TRAILER WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HUB AND FIVE LUG IDLERS, A LUG NUT SET, A SEAL, A REAR TAIL LIGHT, AN EXTRA LUBE CAP, AND A RUBBER PLUG FAILED AND NEEDED TO BE REPLACED. THE TRAILER WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THERE WAS NO APPLICABLE MILEAGE.

COMPLAINT IS RELATIVE TO PERSONAL AND PUBLIC SAFETY, AS WELL AS A FAILURE TO HONOR WARRANTY ON A SET OF TIRES WHICH WORE OUT AT A PRECIPITOUS RATE. A BRAVO CAR-HAULER WAS PURCHASED OCTOBER 2014 IN THUNDER BAY, ONTARIO, CANADA FROM WOODY'S TRAILER WORLD, WHO PURCHASED THE UNIT FOR RE-SALE FROM BRAVO TRAILERS IN BRISTOL INDIANA. THE TRAILER CAME FITTED WITH THE FOLLOWING TIRES: VAIL SPORT ST, MARKED AS ST 225/75D15, H78-15, DOT NMHH 1714, 8 P.R. LOAD RANGE D, TREAD 5 PLIES NYLON, SIDEWALL 3 PLIES NYLON. THE TRAILER WAS MANUFACTURE IN JUN 2014, IS A TANDEM AXLE, EACH RATED AT 5200 POUNDS. THE AXLES ARE DEXTER, AND ARE IN ALIGNMENT CORRECTLY. THE FOUR TIRES IN QUESTION WERE CHECKED BY CONCERNED FRIENDS, THEN BY PROFESSIONALS AFTER THEY WERE IN USE FOR ABOUT 36 HOURS, APPROXIMATELY 3600 KILOMETERS, I.E. 2,160 MILES. THE TIRES, INFLATED CORRECTLY AT 60 P.S.I. AS SHOWN ON THE SIDEWALL IMPRINT AND THE TRAILER SPEC PLATE SHOWED IRREGULAR WEAR PATTERNS, EACH TIRE WEARING DIFFERENTLY, PRONOUNCED DEFORMITY IN SQUARENESS TO THE ROAD MEASURED VERTICALLY, WEAR ON SOME TO THE SIDE OF THE TREAD, AND OUT OF ROUNDNESS. THE TIRES WERE PRONOUNCED UNSAFE, AND HAD TO BE REPLACED FOR SAFETY REASONS. THE DEALER, WOODY'S TRAILER WORLD, HAS NOT HAD A POSITIVE RESPONSE FROM THE TIRE SUPPLIER, LIONSHEAD TIRE AND WHEEL, WHO TRY TO ASSERT THAT THE TIRES WERE OVER INFLATED, WHICH IS NOT TRUE. IT WAS DISCOVERED BY THIS COMPLAINANT THAT THESE TIRES WERE SUBJECT TO A NHTSA RECALL IN FEB. 2014 AND IN JUNE 2014.

I WAS RETURNING TO OAK RIDGE, TN FROM ORLANDO, FL ON 03/21/15. I WAS TOWING A 2014 ALUMA 5410T LOADED WITH (1) EZGO EXPRESS L6 (GAS) GOLF CART (CURB WT: 1020 LBS.), CONTAINING (1) GALLON OF GAS, AND ALSO CARRYING (1) SPARE TIRE. THERE WAS NOTHING ELSE ON TRAILER, EXCEPT THE TIE-DOWN STRAPS. I STOPPED IN THE OAKS MALL PARKING LOT AT 6419 NEWBERRY ROAD, GAINESVILLE, FLORIDA 32605 AROUND 2PM. WHEN I DROVE AT 3 OR 4 MPH OVER A SPEED BUMP, THE TRAILER SEPARATED INTO TWO PIECES. THE FRAME, AXLE, BED, AND CARGO BROKE OFF FROM ARM THAT WAS STILL HITCHED AND CHAINED TO MY RV. THE MAIN PART OF THE TRAILER AND ALL OF THE CARGO WAS COMPLETELY DETACHED FROM MY TOW VEHICLE. I WAS ABLE TO SLOWLY PULL THE TRAILER TO AN EMPTY PART OF THE PARKING LOT, AS THE BODY OF THE TRAILER WAS RESTING ON THE ARM THAT REMAINED HITCHED AND CHAINED TO THE TOW VEHICLE. THERE WERE NO INJURIES. *TR