2010 Club Car Carryall 2 Lsv

Defect. CLUB CARD IS RECALLING CERTAIN MODEL YEAR 2008-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 209 "SEAT BELT ASSEMBLIES." THE SEAT BELT ORIGINALLY PROVIDED WITH THE VEHICLES MEETS SOCIETY OF AUTOMOTIVE ENGINEERS (SAE) STANDARDS INSTEAD. THE DIFFERENCE IN THESE TWO STANDARDS IS THE IMPACT LEVEL AT WHICH THE SEAT BELT RETRACTOR LOCKS.

Risk. THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy. DEALERS WILL REPLACE THE SEAT BELT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 13, 2010. OWNERS MAY CONTACT CLUB CAR AT 1-800-227-0739.

TL* THE CONTACT OWNS A 2010 ELECTRIC CLUB CAR. THE CONTACT STATED THAT WHEN DRIVING AT LOWER SPEEDS, HE WOULD SMELL A BURNING ODOR INSIDE THE VEHICLE. THE CONTACT INSPECTED THE BATTERY AND NOTICED THAT IT WAS ABNORMALLY HOT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE BATTERY CABLES FAILED. THE VEHICLE WAS REPAIRED AND ALL OF THE BATTERY CABLES WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 5,500 (ENERGY UNITS). *TR.. ..UPDATED 04/24/13 *BF THE CONSUMER STATED THE BURNING ODOR WAS PRIMARILY NOTICED WHEN TRAVELING UPHILL. FURTHER INSPECTION INDICATED THAT SOME OF THE BATTERY CABLES CONNECTING THE SIX 8-VOLT BATTERIES WERE GETTING SO HOT THAT THEY COULD NOT BE TOUCHED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, WHERE THEY DETERMINED THAT THERE WERE TWO BAD CROSSOVER CABLES. THEY REPLACED THE TWO CABLES AND INDICATED THAT IT WAS A NORMAL MAINTENANCE ISSUE TO HAVE THE CABLES REPLACED AND THEREFORE, IT WAS NOT COVERED UNDER WARRANTY. WHEN THE CONSUMER RECEIVED HIS VEHICLE, HE NOTICED THE SAME BURNING ODOR COMING FROM SOME OF THE REMAINING CABLES. SURE ENOUGH, THE OTHER CABLE WERE GETTING EXCESSIVELY HOT AS WELL. THE DEALER AGREED TO REPLACE THE REMAINING CABLES, BUT AT THE CONSUMERS EXPENSE, EXCLUDING THE LABOR CHARGE. ...UPDATED 06-19-13 *BF