2001 Chevrolet Redundant Silverado 2500

Defect. CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.

Risk. LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.

Remedy. FABTECH WILL NOTIFY OWNERS AND REPLACE THE PITMAN AND IDLER ARMS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2006. OWNERS MAY CONTACT FABTECH AT 909-597-7800.

Defect. VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.

Risk. THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.

Remedy. DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Unknown Lost my truck to fire I was shopping and when I came out of the store the fire department had already put the fire out. They had said the fire started under the hood on the driver side.

SINGLE OCCUPANT BLACK ICE-INDUCED HEAD ON HIGH FORCE IMPACT TREE COLLISION WHILE WITH NO PRE-TENSIONER OR AIR BAG DEPLOYMENTS OF ONE-OWNER VEHICLE

THIS VEHICLE HAS ABS ACTIVATING BETWEEN 3MPH AND 10MPH WHEN APPLYING THE BRAKES. THERE IS NO CONDITION WARRANTING THE NEED FOR ABS (E.G. WET OR ICY ROADS) WHEN THIS HAPPENS. THERE IS NO CODES OR DASHBOARD LIGHTS FOR THIS ISSUE. THIS ISSUES DOES INCREASE THE STOPPING DISTANCE OF THE VEHICLE, ESPECIALLY ON DIRT ROADS, OR WHEN HAULING HEAVY LOADS. GM IS AWARE OF THIS ISSUE AND IT IS CAUSED BY RUST AROUND THE ABS SENSORS. THERE IS A RECALL (NHTSA CAMPAIGN NUMBER: 05V379000) FOR VEHICLES WITH THIS ISSUE, BUT DESPITE MATCHING THE MAKE, MODEL, YEAR, GEOGRAPHICAL LOCATION AND THE VERY SPECIFIC SYMPTOMS, THIS VEHICLE IS NOT INCLUDED IN THE RECALL FOR SOME REASON. GM HAS TOLD ME TO PAY FOR THE REPAIRS AND HOPE THAT MAYBE SOMEDAY THE RECALL WILL BE UPDATED TO INCLUDE MY VEHICLE.

EXTREME RUST, TAILGATE CABLES BROKE IN USE, HAD TO REPLACE. TAILGATE STILL WON'T LATCH PROPERLY, DROPPING OPEN WHILE DRIVING/HAULING FAIRLY OFTEN; BRAKE LINE RUSTED OUT, REPLACED BEFORE HAD ACCIDENT; WHOLE FRAME RUSTED - UNDER CARRIAGE//TIRE WELLS/DRIVE SHAFT/AROUND REECE HITCH SO I WORRY ABOUT PULLING TRAILER/HAILING. HORN HAS RUSTED OFF. ONLY 77,000 MILES AS I DO NOT DRIVE IT DAILY, JUST TO WORK AROUND MY PLACE OR PICKUP/HAUL/TRAILER SOMETHING. GM NEEDS RECALL TO ADDRESS THIS RUST ISSUE BECAUSE IT IS A MAJOR SAFETY ISSUE.

MY TRUCK WAS PARKED OUTSIDE MY HOUSE AND THIS DRUNK DRIVER HIT MY TRUCK IN THE MIDDLE OF THE NIGHT.AND MEST UP ALL OF ONE SIDE OF THE TRUCK INCLUDING MY ENGINE,BABY SEATS AND TIRES AND WINDOWS.

RUSTED BRAKE LINES X-2 ,BRAKES FAILED AND PEDAL WENT TO THE FLOOR, STOPPED IN TIME NO WRECK, HAD TO SPLICE LINE WITH COUPLINGS.

TOTAL BRAKE FAILURE WHILE ATTEMPTING TO STOP DUE TO RUSTED BRAKE LINE. BRAKE LINES LEADING TO REAR BRAKES AND LEFT FRONT RUSTED THROUGH AND BLED OUT. I WAS TRAVELLING 55MPH.

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500. WHILE DRIVING AT ANY SPEED, THE BRAKE LINES OFTEN FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKES NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED TWICE, BUT THE FAILURE RECURRED MANY TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. UPDATED 09/20/16*LJ *TR

THIS IS THE 5TH TIME MY BRAKES ARE HANGING UP AND OVER HEATING THE WHEEL. SMOKING SEVERLY. HAD PROBLEM WITH ABS. SYSTEM SO I UNPLUGGED SENSORS FROM FRONT WHEELS. AND ON THE 1ST THE RIGHT PASSENGER SIDE DID IT AGAIN. DOESN'T MATTER IF ON STATE HWY OR CITY STREETS. ALWAYS STARTS WHEN MOVING. A WOBBLE IN STEERING WHEEL. THEN PULLING RIGHT OR LEFT DEPENDING ON WHICH WHEEL IS LOCKING.

BRAKE LINES RUSTED OUT AND ALLOWED BRAKE FLUID TO LEAK OUT WHEN I APPLIED THE BRAKES. HAD VEHICLE TOWED TO CURRY AUTO IN BLOOMINGTON, IN FOR REPLACEMENT OF RUSTED BRAKE LINES. THIS HAPPENED A SECOND TIME ABOUT TWO MONTHS LATER WHEN ANOTHER ORIGINAL SET OF BRAKE LINES UNDER THE BED OF THE TRUCK RUSTED THROUGH AND CAUSED BRAKE FAILURE. BOTH TIMES I WAS DRIVING IN HILLY COUNTRY AND WAS FORTUNATE NOT TO CRASH INTO SOMETHING. DEALER SAID THAT THIS IS A COMMON PROBLEM WITH SILVERADO TRUCKS OF BRAKE LINES RUSTING OUT. I HAVE A 1996 BUICK ROADMASTER THAT HAS RUSTED OUT QUARTER PANELS AND THE BRAKE LINES ARE ORIGINAL.THIS TRUCK IS RUST FREE EXCEPT FOR THE BRAKE LINES. GM SHOULD PAY FOR THE REPLACEMENT OF THE BRAKE LINES ON THESE TRUCKS. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE VEHICLE IDLED ROUGHLY, CAUSING THE ENGINE TO STALL. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CRANKSHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED UNDER NHTSA CAMPAIGN NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 114,000.

FIRST INCIDENT: VEHICLE DRIVEN 100 MILES AND THEN SHUT OFF FOR ABOUT 6 HOURS. STARTED RIGHT UP AND MOVED ABOUT 100 YARDS AND SHUT OFF FOR ABOUT 30 MINUTES. TRIED TO START IT AND WOULDN'T START. AFTER ABOUT 15 MINUTES, IT STARTED AND VEHICLE DRIVEN HOME WITHOUT FURTHER PROBLEM. SECOND INCIDENT, VEHICLE STALL WHILE MOVING IN CITY TRAFFIC (ABOUT 35 MPH). CAME TO A STOP AT THE BOTTOM OF A BUSY UNDERPASS NEAR A MAJOR INTERSECTION. I CALLED 911 AND ASKED THAT A WRECKER BE DISPATCHED. AS 911 WAITING FOR A RESPONSE FROM THE WRECKER COMPANY (TWO TO THREE MINUTES), THE VEHICLE STARTED AND I RETURNED TO MY RESIDENCE. SCAN WITH OBD DEVICE INDICATED CRANKSHAFT POSITION SENSOR FAILURE. INTERNET RESEARCH OF THE PROBLEM CONFIRMS. YOUR INVESTIGATION EA06-016 AND SUBSEQUENT NHTSA CAMPAIGN NUMBER 07V521000 CRANKSHAFT POSITION SENSOR INDICATES A SAFETY RECALL. FOR SOME REASON, GM (DENNY MENHOLT CHEVROLET) AS WELL AS YOUR WEBSITE, INDICATES NO RECALLS ON THIS VEHICLE. I HAVE AN APPOINTMENT AT THE ABOVE DEALERSHIP ON 10/22 TO HAVE THE CPS REPLACED. WHY ISN'T MY VEHICLE PART OF THE RECALL? THE STALL WHILE MOVING AT 35 MPH WAS DANGEROUS AND THE REPAIR IS EXPENSIVE! THANK YOU. I LOOK FORWARD TO HEARING FROM YOU. *TR

DRIVING TO WORK WHEN I USE MY BRAKES THEY FELT SOFT THE NEXT TIME I USED THEM THE PEDDLE WENT TO THE FLOOR. AFTER STOPPING MY TRUCK I SEE A RUSTY BRAKE LINE UNDER MY TRUCK HAD A HOLE IN IT AND FLUID WAS POURING OUT. *TR

BRAKE PEDAL WENT TO FLOOR AFTER LAUNCHING MY BOAT. FOUND THAT A BRAKE LINE HAD RUPTURED. GLAD IT DIDN'T HAPPEN WHILE I WAS ON THE ROAD WITH THE BOAT IN TOW. ALL BRAKES LINES WERE RUSTED AND I HAD THEM REPLACED FOLLOWING WEEK. VERY EXPENSIVE REPAIR. FOUND OUT THIS IS COMMON ON THESE VEHICLES. GM REALLY NEEDS TO FIX THIS ISSUE. *TR

ON THE WAY TO PICK UP SOME ITEMS FROM A RELATIVE THAT LIVED 42 MILES, APPROXIMATELY 32 MILES INTO THE TRIP IT WAS NOTICED THAT THE BRAKES WERE GETTING PROGRESSIVELY WORSE, WITHIN 4 MILES OF OUR DESTINATION, THE BRAKES WERE ALMOST NON-EXISTENT. FORTUNATELY, WE MADE IT, HOWEVER AS SOON AS WE PARKED AND TURNED THE ENGINE OFF, WE HEARD A POP AND LIQUID BEGAN SPRAYING FROM THE RIGHT SIDE OF THE FRONT GRILL NEAR THE HEADLIGHT. A VERY LARGE AMOUNT OF LIQUID THEN BEGAN POURING OUT OF THE RIGHT SIDE BY THE BUMPER AS WELL. ORIGINALLY WE BELIEVED IT TO BE COOLANT AS IT HAD A GREEN TINT TO IT, HOWEVER THIS DIDN'T EXPLAIN THE POOR BRAKE RESPONSE. WE THOUGHT PERHAPS THE BRAKE FLUID WAS LOW, AND CHECKED THE RESERVOIR. THE RESERVOIR HAD SOME STILL, BUT SHOWED LOW. WE ADDED SOME, BUT IT POURED OUT ALMOST AS FAST AS IT WENT IN. UPON FURTHER INVESTIGATION WE FOUND THE LEAK NOT TO BE COOLANT, BUT THE ACTUAL BRAKE LINES HAD BLOWN OUT DUE TO RUST, AND WHAT SPRAYED OUT WAS BRAKE FLUID MIXED WITH RUST. HAD THIS HAPPENED 20 MINUTES LATER, AFTER WE WOULD HAVE LOADED A LARGE AMOUNT OF BRICKS IN THE BED, AND WE HAD TO STOP SUDDENLY, THIS COULD HAVE BEEN DISASTROUS AND EVEN DEADLY. WE LEARNED ABOUT THIS SITE BY LOOKING ONLINE AND SEEING THE TENS OF THOUSANDS OF COMPLAINTS OF THE SAME THING - CHEVROLET SAVING A FEW DOLLARS AND USING STEEL FOR BRAKE LINES INSTEAD OF STAINLESS STEEL - A COST OF LESS THAN $40 PER VEHICLE (WE PRICED REPLACEMENTS AND THE STEEL WAS $195, WHILE STAINLESS STEEL WAS $233), AND NO

I HAD JUST REPLACED THE HUB AND BEARING HOUSING ON THE RIGHT FRONT AXLE ON MY FOUR WHEEL DRIVE 2001 CHEVROLET HD2500 SILVERADO PICKUP AND WAS IN THE PROCESS OF REFILLING AND BLEEDING THE AIR FROM THE BRAKE LINES. DURING THIS PROCESS IT APPEARED AS IF IT WAS REQUIRING MORE FLUID THAN I HAD REMOVED IT WAS THEN THAT I NOTICED BRAKE FLUID DRIPPING FROM THE LEFT FRONT WHEEL WELL. TO MY SURPRISE AFTER REMOVING THE PLASTIC WHEEL WELL COVER I COULDN'T BELIEVE MY EYES AT WHAT I SAW, THERE WERE THE BRAKE LINES EITHER RUSTED AWAY OR DELAMINATED. I HAVE NEVER EXPERIENCED ANYTHING LIKE THIS IN OVER FIFTY YEARS OF REPAIRING MY OWN VEHICLES, I CAN ONLY BE THANKFUL THAT I WASN'T ON THE ROAD TOWING MY FIFTH WHEEL TRAILER WHEN THE BRAKE LINES FAILED IN SUCH A CATASTROPHIC MANNER. SINCE THIS HAPPENED LATE IN OCTOBER OF 2013 I HAVE YET TO REPLACE THE BRAKE LINES, IF YOU NEED PICTURES OF THE PROBLEM I CAN PROVIDE THEM TO YOU. *TR

I WAS DRIVING ON US 41 WHEN THE LIGHT STARTED TO CHANGED I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR, THE REAR BRAKE LINE BURST, THIS FIRST OCCURRENCE WAS IN SEPT 2012, THEN THIS NOVEMBER THE SAME THING OCCURRED ACCEPT THE FRONT BRAKE LINE BURST. BOTH TIMES I HAD THE CHEVROLET DEALER PERFORM THE REPAIRS. THE SECOND REPAIR ,I WAS INFORMED BY THE SERVICE TECH THAT THIS OCCURS WITH TRUCKS THAT ARE IN THE NORTHERN STATES QUITE OFTEN AND IS DUE TO CORROSION THAT ATTACKS THE CARBON STEEL BRAKE LINES. I WAS VERY LUCKY IN BOTH BRAKE FAILURES THAT NOBODY WAS IN FRONT OF ME, OTHERWISE THERE WOULD HAVE BEEN POSSIBLE INJURIES.. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500. THE CONTACT STATED THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 60 MPH. THE VEHICLE RETURNED TO NORMAL FUNCTION AFTER BEING RESTARTED AND WAS TAKEN TO A MECHANIC FOR DIAGNOSTIC TESTING. THE DEALER ADVISED THAT THE 02 SENSOR HAD FAILED HOWEVER, THE 02 SENSOR DID NOT CAUSE THE VEHICLE TO STALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 110,000.

BRAKE LINE CORROSION CAUSED TOTAL BRAKE SYSTEM FAILURE. FORTUNATELY, NO ONE WAS INJURED OR KILLED. *TR

BRAKES COMPLETELY FAILED. *TR